2007 Volvo XC90 recalls and problems

The 2007 Volvo XC90 has 2 safety recalls and 38 owner complaints filed with NHTSA. Recall repairs are free at any Volvo dealer.

Recalls

Complaints

Crashes / fires

0 / 5

Injuries / deaths

0 / 0

Recalls may cover only some 2007 Volvo XC90 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2007 Volvo XC90 recalls

Recall 10V-566: Equipment

Reported Nov 8, 2010 · 416 vehicles affected · VOLVO CARS OF N.A. LLC.

Problem: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (Gps) units because the batteries on those units may overheat.

Risk: An overheated battery could lead to a fire.

Fix: Volvo advises owners to please stop using the garmin portable GPS device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

Recall 07V-563: Visibility

Reported Dec 12, 2007 · 37,000 vehicles affected · VOLVO CARS OF N.A. LLC.

Problem: On certain sport utility vehicles, under certain conditions, the climate control module (Ccm) may receive a 'shut-down signal' from the engine control module (Ecm) after ignition key insertion. If this condition occurs, the climate control functions will not be available (Including the defroster) during that driving cycle.

Risk: Inoperative defrosters under inclement weather conditions could cause impaired visibility which has the potential to result in personal injury and/or vehicle and property damage.

Fix: The ECM software will be upgraded. The recall began on january 28, 2008. Owners may contact volvo at 1-800-458-1552.

2007 Volvo XC90 problems reported by owners

Problem area	Reports
Electrical System	14
Power Train	7
Steering	4
Engine	4
Unknown or Other	4
Suspension	3
Exterior Lighting	3
Fuel/Propulsion System	3
Engine and Engine Cooling	2
Service Brakes, Hydraulic	2
Wheels	2
Service Brakes	2

Most reported parts

Power Train › Automatic Transmission — 2
Engine and Engine Cooling › Engine — 1
Service Brakes, Hydraulic › Foundation Components › Disc › Rotor — 1
Engine and Engine Cooling › Cooling System › Fan — 1
Power Train › Automatic Transmission › Lever and Linkage › Floor Shift — 1
Power Train › Automatic Transmission › Park/Neutral Start Interlock Switch — 1
Electrical System › 12v/24v/48v Battery — 1
Suspension › Front › Control Arm › Upper Ball Joint — 1

Typical mileage at the time of the problem: 75,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2007 Volvo XC90 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · reported Feb 2, 2026

While driving the vehicle under normal conditions, a sudden electrical fire occurred, requiring immediate evacuation. The vehicle was pulled over safely and the driver exited before the fire escalated. The fire department responded and the vehicle was declared a total loss due to fire damage. The failure is believed to have originated from an electrical short involving the climate control/defroster system. The affected wiring and components were destroyed by the fire and are not available for inspection. The day prior to the fire, the fuse controlling both the climate control system and the…

Air Bags · at 80,000 miles · reported Dec 29, 2023

The contact owns a 2007 Volvo XC90. The contact stated that the air bag warning light was illuminated on the instrument cluster. The local dealer was contacted, and it was diagnosed that the failure was due to the air bag module. The vehicle was repaired, but the failure recurred. The vehicle was taken to an independent mechanic, but the result was unknown. The manufacturer was contacted, and a recorded message referred her to the dealer. The approximate failure mileage was 80,000.

Fuel/Propulsion System · reported Nov 27, 2023

I am writing to bring to your attention a concerning matter regarding my recently acquired 2007 Volvo XC90. Upon refueling the vehicle to a level exceeding half the tank capacity, there is a discernible and persistent odor of gasoline within the cabin. Given the potential safety implications associated with such an issue, I am seeking your guidance on the appropriate course of action. In researching this matter, I have come across similar concerns raised by other owners of the same vehicle model. This has heightened my awareness of the need to address this issue promptly and comprehensively.…

Fuel/Propulsion System · reported Sep 2, 2023

Drivers side fuel tank sending unit print or sending unit top leaking fuel, a check engine light appeared and almost instantly started smelling like gas. The check engine said small evap leak. This is a huge safety concern for my family and I. No further action has been done.

Fuel/Propulsion System · reported Dec 13, 2022

IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. This Recall Was Done for a 2004 Volvo xc90 . I am currently Experiencing the same problem with my 2007 volvo Xc90 AWD. Every time, I fill up to 1/2 a tank or full , I start to smell the fumes inside the vehicle . I took it to get inspected , and the mechanic said the fuel pump assembly usually cracks and the vapor goes inside the cabin. I personally think this is not safe for us drivers or the passengers. living in Arizona with high temperatures…

Other Volvo XC90 years

2025 2024 2023 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 200820072006 2005 2004 2003

Compare all Volvo XC90 years · All Volvo models

Frequently asked questions

Does the 2007 Volvo XC90 have any recalls?

Yes — NHTSA lists 2 recalls for the 2007 Volvo XC90: 10V-566 (equipment), 07V-563 (visibility). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2007 Volvo XC90?

Owners report electrical system problems most often (14 reports), followed by power train (7). The typical mileage when problems were reported is about 75,000 miles.

Are Volvo recall repairs free?

Yes. Safety recall repairs are free at authorized Volvo dealers, whether you are the first owner or bought the car used.