There are no safety recalls for the 2009 Ford F-250 SD, but owners have filed 23 complaints with NHTSA.
2009 Ford F-250 SD problems reported by owners
| Problem area | Reports | |
|---|
| Steering | 7 | |
| Suspension | 7 | |
| Engine and Engine Cooling | 5 | |
| Wheels | 3 | |
| Engine | 2 | |
| Exterior Lighting | 1 | |
| Power Train | 1 | |
| Tires | 1 | |
| Fuel System, Diesel | 1 | |
| Trailer Hitches | 1 | |
| Fuel System, Gasoline | 1 | |
| Seat Belts | 1 | |
Most reported parts
- Engine and Engine Cooling › Engine — 2
- Engine and Engine Cooling › Exhaust System — 1
- Power Train › Automatic Transmission — 1
Typical mileage at the time of the problem: 30,507 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2009 Ford F-250 SD complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Service Brakes · at 40,000 miles · reported Feb 17, 2017
My f-250 has had every brake caliper lock up and cause total brake system failure and repair. Starting at 40k miles it is out of warranty but there is an obvious defect in the design if every caliper has had this problem. My shop did a repair history search and found that the 2009s had a higher failure rate than other years. I also had the manifold warp and needed replacement at just 40k miles. Thanks - dan
Steering · at 98,000 miles · reported Jun 7, 2016
The contact owns a 2009 ford f-250 sd. While driving 55 MPH over a pothole, the vehicle started to shake violently without warning. Once the speed was reduced, the vehicle stopped shaking. The vehicle was taken to the dealer. The technician replaced the track bar, ball joint, bushing, and the steering damper. The remedy failed to repair the issue. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 98,000.
Steering · at 180,000 miles · reported Jun 2, 2016
The contact owns a 2009 ford f-250 sd. The contact stated that the front end of the vehicle was unstable shook and vibrated excessively with an extreme wobble. The dealer was notified of the failure and was unable to provide a repair solution to prevent the failure. The contact took the vehicle to more than five different repair shops for various repairs, but the failures continued in the front and rear ends. The vehicle was not repaired and the contact was waiting to determine if the manufacturer would be able to provide a permanent repair solution. The approximate failure mileage was…
Engine · at 21,478 miles · reported Mar 29, 2015
We own a 2009 ford f250 super duty 4x4, with low miles (21478). This vehicle has run great since we purchased it new. As we were driving, the engine began to run poorly and loose power. The engine light then came on. The mechanic scanner the engine codes p0012-p0018-p0022-p0341-p052d, indicating faulty cam phasers and tensioners, and that the engine was out of time. This pickup has low mileage and all the recommended maintenance has always been done. The ford parts department stated that they keep these parts stocked because it is a common repair issue.
Suspension · at 151,500 miles · reported Mar 10, 2015
Hit a small bump and truck shakes violently. Shaking does not stop until vehicle is slowed down or completely stopped. It has happened 14 times at speeds ranging from 40 MPH to 75 MPH. Alignment is fine, tires balanced and at 50% life, new shocks, new steering damper and suspension components show no sign of wear. Despite this, problem persists and is actually becoming more frequent.
Frequently asked questions
Does the 2009 Ford F-250 SD have any recalls?
No. NHTSA has no safety recalls for the 2009 Ford F-250 SD as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2009 Ford F-250 SD?
Owners report steering problems most often (7 reports), followed by suspension (7). The typical mileage when problems were reported is about 30,507 miles.
Are Ford recall repairs free?
Yes. Safety recall repairs are free at authorized Ford dealers, whether you are the first owner or bought the car used.