2007 Volvo S40 recalls and problems

The 2007 Volvo S40 has 2 safety recalls and 25 owner complaints filed with NHTSA. Recall repairs are free at any Volvo dealer.

Recalls

Complaints

Crashes / fires

4 / 1

Injuries / deaths

5 / 0

Recalls may cover only some 2007 Volvo S40 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2007 Volvo S40 recalls

Recall 10V-566: Equipment

Reported Nov 8, 2010 · 416 vehicles affected · VOLVO CARS OF N.A. LLC.

Problem: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (Gps) units because the batteries on those units may overheat.

Risk: An overheated battery could lead to a fire.

Fix: Volvo advises owners to please stop using the garmin portable GPS device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

Recall 08V-101: Service Brakes, Hydraulic

Reported Mar 5, 2008 · 1,114 vehicles affected · VOLVO CARS OF N.A. LLC.

Problem: Volvo is recalling 1,114 my 2007 c30, c70, s40, and v50 passenger vehicles. A soft anodized layer in the master cylinder may trigger early wear on a rubber seal that can result in internal leakage of brake fluid. If affected, the driver may experience reduced brake performance when applying and maintaining force of the brake pedal.

Risk: The capacity to brake will gradually deteriorate forcing the driver to use a higher than expected force on the brake pedal when compared to an intact brake system. The deterioration can eventually result in complete loss of the brake system functionality increasing the risk of a crash.

Fix: Dealers will inspect the master cylinder. The brake master cylinder and brake fluid reservoir will be replaced and certain brake lines cleaned free of charge. The recall began on march 11, 2008. Owners may contact volvo at 1-800-458-1552.

2007 Volvo S40 problems reported by owners

Problem area	Reports
Electrical System	5
Service Brakes, Hydraulic	4
Engine and Engine Cooling	3
Unknown or Other	3
Power Train	2
Seat Belts	2
Steering	2
Engine	2
Air Bags	2
Vehicle Speed Control	2
Latches/Locks/Linkages	1
Service Brakes, Electric	1

Most reported parts

Power Train › Clutch Assembly › Pedal/Hand Lever(Motorcycle) — 1
Engine and Engine Cooling › Cooling System — 1
Service Brakes, Hydraulic › Foundation Components › Disc › Caliper — 1
Power Train › Automatic Transmission — 1
Electrical System › Ignition › Switch — 1
Seat Belts › Front — 1
Visibility › Defroster/Defogger/Hvac System — 1

Typical mileage at the time of the problem: 60,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2007 Volvo S40 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · at 99,000 miles · reported Sep 22, 2020

On or about 12/04/2019 during a flash rain storm last winter, my husband and I was headed home on the 215 fwy northbound in san bernardino, ca when the center dome area and the electric sunroof inside our car begin pouring in huge amounts of very cold rain water on us and on the dashboard, stereo console, gear shifter, floor and seats. Until it was safe to exit the freeway, my husband tried to soak up as much of the leaking rainwater as he could with his coat but the water continued to pouring into the car. Once it was safe to exit the freeway, we pulled into a gas station and examine the…

Steering · at 124,000 miles · reported May 6, 2019

I was driving and the engine shut off causing me to lose control of my vehicle as the power steering shut down. I was able to steer my vehicle with difficulty to the side of the road where it stopped. About one week later this happened again. This time I was coming out of a parking lot and had to aim my vehicle in a way to avoid hitting other vehicles. Both time, after a few minutes the car started right up and I was able to drive again. Last friday, may 3, I pulled my vehicle over and when I stopped the vehicle shut down. This time it did not restart. The error message displayed on the dash…

Seat Belts · at 60,000 miles · reported Oct 19, 2018

The contact owned a 2007 volvo s40. The contact called on behalf of the driver. The contact stated that the vehicle was struck on the front passenger side by another vehicle. The speed was unknown. The air bag failed to deploy and the seat belt detached. The driver sustained leg, back, and shoulder injuries that required medical attention. A police report was filed. The vehicle was destroyed and towed to a tow lot. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing. The manufacturer was not notified of the failure. The approximate failure mileage was…

Electronic Stability Control (ESC) · at 104,000 miles · reported May 31, 2018

After parking car and turning car off, airbag, brake, and information warning lights stay on, as does ventilation system. Passenger seat has excess water underneath. Now car will not start.

Vehicle Speed Control · at 10 miles · reported Feb 2, 2017

Vehicle loses power due to accelerator pedal low voltage/signal. This occurs in multiple situations. Safest is shortly after starting the car an engine light stating 'engine system urgent' appears. Unsafe occurrence includes power loss while pedal is depresses such as on the highway with constant pressure or most severe when turning left through an intersection power is reduced to idle. If the vent occurs with the pedal repressed, power is reduced to idle momentarily (2-3 seconds) and after 'pumping' the pedal several times it returns to normal. I have brought this vehicle several times to…

Other Volvo S40 years

2011 2010 2009 200820072006 2005 2004 2003 2002 2001 2000

Compare all Volvo S40 years · All Volvo models

Frequently asked questions

Does the 2007 Volvo S40 have any recalls?

Yes — NHTSA lists 2 recalls for the 2007 Volvo S40: 10V-566 (equipment), 08V-101 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2007 Volvo S40?

Owners report electrical system problems most often (5 reports), followed by service brakes, hydraulic (4). The typical mileage when problems were reported is about 60,000 miles.

Are Volvo recall repairs free?

Yes. Safety recall repairs are free at authorized Volvo dealers, whether you are the first owner or bought the car used.