Home › Workhorse › W20 › 2006

2006 Workhorse W20 recalls and problems

The 2006 Workhorse W20 has 2 safety recalls and 3 owner complaints filed with NHTSA. Recall repairs are free at any Workhorse dealer.

Recalls
2
Complaints
3
Crashes / fires
0 / 0
Injuries / deaths
0 / 0

Recalls may cover only some 2006 Workhorse W20 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2006 Workhorse W20 recalls

Recall 09V-110: Service Brakes, Hydraulic

Reported Apr 3, 2009 · 48,876 vehicles affected · NAVISTAR, INC

Problem: Navistar is recalling certain model year my 2001-2008 workhorse w20, w21 and w22 chassis and certain model year 2009 through 2011 monaco rv admiral, arista, monarch, and riptide recreational vehicles equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.

Risk: The temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.

Fix: Workhorse dealers will replace all four bosch brake caliper assemblies free of charge. The safety recall began on september 16, 2010. Owners may contact workhorse at 1-877-246-7731.

Recall 06V-148: Steering

Reported May 2, 2006 · 3,881 vehicles affected · WORKHORSE CUSTOM CHASSIS

Problem: Certain chassis may have been equipped with incorrect steering intermediate shafts. The spline can strip while the steering wheel is being turned.

Risk: This steering condition could increase the risk of a crash.

Fix: Dealers will inspect and, if necessary, replace the steering intermediate shafts. The recall began on may 22, 2006. Owners may contact workhorse at 1-877-294-6773.

2006 Workhorse W20 problems reported by owners

Problem areaReports
Service Brakes, Hydraulic2
Steering1

Typical mileage at the time of the problem: 12,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2006 Workhorse W20 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes, Hydraulic · at 24,000 miles · reported Nov 22, 2010
The contact owns a 2006 monaco coach monarch se rv equipped with a workhorse w20 chassis. The contact referenced recall 09v110000 (Service brakes, hydraulic) and stated that the recall repair was performed on october 26, 2010. The dealer returned the vehicle with the left front rotor cracked and the pad had 30% left. The contact stated that the other brakes were at 70% with no cracks. The contact called the manufacturer who had not responded. The VIN was unavailable. The current and failure mileages were approximately 24,000.
Service Brakes, Hydraulic · at 12,000 miles · reported Jun 15, 2009
While driving on the DC beltway in traffic, the brake pedal went to the floor without stopping. Pumping the pedal gave enough power to stop vehicle. Abs warning light also came on. Stopped vehicle on side of road. Brakes were very hot. Disconnected car we were towing and attempted to continue. Brakes did cool off and returned to normal operation. We had previously towed the car without any problems. Rv was taken to an authorized shop about 5 miles from campground. They said they knew about the problem and could "patch" it until workhorse came out with a fix.
Steering · at 760 miles · reported Nov 6, 2006
The steering on my 2007/2006 workhorse w-20 chassis is extremely/dangerously loose in that it is very difficult to drive safely during minimal environmental conditions of winds and passing vehicles. I compare this vehicle to three other motorhomes with workhorse chassis and 110,000 + miles of accident free driving.

Other Workhorse W20 years

200820072006200520042003200220012000

Compare all Workhorse W20 years · All Workhorse models

Frequently asked questions

Does the 2006 Workhorse W20 have any recalls?

Yes — NHTSA lists 2 recalls for the 2006 Workhorse W20: 09V-110 (service brakes, hydraulic), 06V-148 (steering). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2006 Workhorse W20?

Owners report service brakes, hydraulic problems most often (2 reports), followed by steering (1). The typical mileage when problems were reported is about 12,000 miles.

Are Workhorse recall repairs free?

Yes. Safety recall repairs are free at authorized Workhorse dealers, whether you are the first owner or bought the car used.