2006 Volvo VNL recalls and problems
The 2006 Volvo VNL has 7 safety recalls and 7 owner complaints filed with NHTSA. Recall repairs are free at any Volvo dealer.
Recalls may cover only some 2006 Volvo VNL vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2006 Volvo VNL recalls
Recall 10V-282: Steering
Problem: Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated may result in a ball socket separation.
Risk: Ball socket separation at the drag link results in complete loss of steering, and therefore can result in a vehicle crash.
Fix: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, volvo trucks mailed an interim owner letter on september 2, 2010. The safety recall began on february 14, 2011. Owners may contact volvo trucks at 1-800-528-6586.
Recall 09V-173: Visibility
Problem: Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal may fail allowing water and contaminants to seep into the windshield wiper motor.
Risk: If this happens a short circuit may occur, which over time could possibly lead to a vehicle fire.
Fix: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, volvo will release the recall in stages as parts are received. Priority will be given to the vehicles located in the regions/states that have a corrosive environment. The recall began on september 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.
Recall 09V-030: Service Brakes, Air
Problem: Volvo trucks is recalling 366 my 2006-2009 vnl trucks equipped with super single tires, bendix brake cam tubes, and volvo air suspension. The vibration frequency from the suspension with super single tires may result in a fatigue crack of the mounting brackets for the brake cam tube.
Risk: If left untreated, the crack can propagate and cause failure of the brake cam tube support bracket(S), which can result in loss of brakes at the corresponding wheel end increasing the risk of a crash.
Fix: Dealers will add a support bracket to the brake cam tube. The recall began on june 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.
Recall 07V-573: Electrical System
Problem: On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system may not provide adequate protection.
Risk: If a short circuit occurs and is left untreated, components and wiring may be subject to overheating which could possibly result in a vehicle fire.
Fix: Dealers will replace the circuit breakers with fuses. The recall began on february 25, 2008. Owners may contact volvo trucks at 1-800-528-6586.
Recall 06V-021: Engine and Engine Cooling
Problem: On certain trucks equipped with d12d engines, the exhaust gas recirculation (Egr) cooler inlet pipes or the pipes that connect the EGR valves to the cooler may crack or break.
Risk: If the pipes or the cooler inlet pipes fail and are left untreated, the air cleaner and inner fender may be subject to hot exhaust gases, which could lead to a fire.
Fix: Dealers will inspect and repair the EGR cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on february 17, 2006, to advise on precautions that the owner can take until parts become available. Owners are being notified starting march 3, 2006, that parts are now available. Owners may contact volvo trucks at 1-800-528-6586.
Recall 05V-498: Wheels
Problem: Certain trucks equipped with front steer axle air suspension may develop a front wheel wobble when the tires become worn.
Risk: If the wobble persists and is left untreated, damage may occur which could impair vehicle control and a crash could occur without prior notice.
Fix: Dealers will repair and replace the front vertical shocks on each side of the front suspension and add a horizontal stabilizer. The recall began on february 20, 2006. Owners may contact volvo trucks at 1-800-528-6586.
Recall 05V-346: Equipment
Problem: Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the tire size designation on the certification label is not shown.
Risk: The certification label is incorrect giving improper information.
Fix: Dealers will replace the certification labels. The recall began on september 12, 2005. Owners may contact volvo trucks at 1-800-528-6586.
2006 Volvo VNL problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Suspension | 3 | |
| Steering | 3 | |
| Exterior Lighting | 2 | |
| Air Bags | 1 | |
| Wheels | 1 | |
| Tires | 1 |
Most reported parts
- Suspension › Front — 1
- Suspension › Multiple Axle — 1
- Wheels › Lugs/Nuts/Bolts/Studs — 1
Typical mileage at the time of the problem: 300,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Volvo VNL complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Volvo VNL years
Frequently asked questions
Does the 2006 Volvo VNL have any recalls?
Yes — NHTSA lists 7 recalls for the 2006 Volvo VNL: 10V-282 (steering), 09V-173 (visibility), 09V-030 (service brakes, air), 07V-573 (electrical system), 06V-021 (engine and engine cooling) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2006 Volvo VNL?
Owners report suspension problems most often (3 reports), followed by steering (3). The typical mileage when problems were reported is about 300,000 miles.
Are Volvo recall repairs free?
Yes. Safety recall repairs are free at authorized Volvo dealers, whether you are the first owner or bought the car used.