2002 Volvo VNL recalls and problems
The 2002 Volvo VNL has 7 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Volvo dealer.
Recalls may cover only some 2002 Volvo VNL vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2002 Volvo VNL recalls
Recall 10V-282: Steering
Problem: Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated may result in a ball socket separation.
Risk: Ball socket separation at the drag link results in complete loss of steering, and therefore can result in a vehicle crash.
Fix: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, volvo trucks mailed an interim owner letter on september 2, 2010. The safety recall began on february 14, 2011. Owners may contact volvo trucks at 1-800-528-6586.
Recall 09V-173: Visibility
Problem: Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal may fail allowing water and contaminants to seep into the windshield wiper motor.
Risk: If this happens a short circuit may occur, which over time could possibly lead to a vehicle fire.
Fix: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, volvo will release the recall in stages as parts are received. Priority will be given to the vehicles located in the regions/states that have a corrosive environment. The recall began on september 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.
Recall 03V-516: Equipment
Problem: On certain heavy-duty trucks, when the bunk is raised into the stored position, an object left on the bunk may inadvertently turn on a bunk lamp.
Risk: This could possibly result in a fire.
Fix: Dealers will install a bunk lamp with a push button on/off switch. Owner notification began on december 24, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo truck at 1-800-528-6586.
Recall 03V-260: Electrical System
Problem: On certain trucks, the wiring harness connected to the chassis mounted electrical inverter may allow water to enter the inverter and cause an electrical short in the inverter.
Risk: This could result in a fire.
Fix: Dealers will replace the wiring harness on these vehicles. Owner notification is expected to begin during august 2003. Owners should contact volvo trucks at 1-800-528-6586.
Recall 03V-204: Trailer Hitches
Problem: On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Risk: If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash.
Fix: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616-846-7700 or by email to recall@jostinternational.com or volvo truck at 800-528-6586.
Recall 03V-199: Suspension
Problem: On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Risk: Seizure of the bearings can cause wheel separation or wheel end fire.
Fix: Dealers will replace all front axle hubs. An interim notice to owners was mailed on june 25, 2003. Final owner notification began on october 6, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-528-6586.
Recall 02V-238: Exterior Lighting
Problem: Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Risk: It may not allow the driver of a rearward approaching vehicle to have full view of the lamps.
Fix: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began october 31, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
2002 Volvo VNL problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Service Brakes, Air | 1 |
Typical mileage at the time of the problem: 159,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2002 Volvo VNL complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Volvo VNL years
Frequently asked questions
Does the 2002 Volvo VNL have any recalls?
Yes — NHTSA lists 7 recalls for the 2002 Volvo VNL: 10V-282 (steering), 09V-173 (visibility), 03V-516 (equipment), 03V-260 (electrical system), 03V-204 (trailer hitches) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2002 Volvo VNL?
Owners report service brakes, air problems most often (1 reports). The typical mileage when problems were reported is about 159,000 miles.
Are Volvo recall repairs free?
Yes. Safety recall repairs are free at authorized Volvo dealers, whether you are the first owner or bought the car used.