Home › Ford › E-450 › 2001

2001 Ford E-450 recalls and problems

The 2001 Ford E-450 has 2 safety recalls and 16 owner complaints filed with NHTSA. Recall repairs are free at any Ford dealer.

Recalls
2
Complaints
16
Crashes / fires
0 / 0
Injuries / deaths
0 / 0

Recalls may cover only some 2001 Ford E-450 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2001 Ford E-450 recalls

Recall 09V-399: Vehicle Speed Control

Reported Oct 13, 2009 · 4,500,000 vehicles affected · FORD MOTOR COMPANY

Problem: Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (Scds). The scds may leak internally and then overheat, smoke, or burn.

Risk: A vehicle fire could occur with or without the engine running.

Fix: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.

Recall 06V-286: Vehicle Speed Control

Reported Aug 1, 2006 · 1,200,000 vehicles affected · FORD MOTOR COMPANY

Problem: On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.

Risk: Overheating could result in smoke or burn and an underhood fire.

Fix: Dealers will install a fused wiring harness into the speed control system free of charge. The recall began on august 7, 2006. Owners may contact ford at 1-866-436-7332. (Note: also see recalls 05v017 and 05v388)

2001 Ford E-450 problems reported by owners

Problem areaReports
Tires8
Suspension5
Service Brakes, Hydraulic3
Engine and Engine Cooling3
Air Bags1

Most reported parts

  • Tires › Tread/Belt — 5
  • Engine and Engine Cooling › Engine — 3
  • Service Brakes, Hydraulic › Foundation Components — 2
  • Suspension › Rear — 1
  • Suspension › Front — 1
  • Suspension › Front › Springs › Coil Springs — 1
  • Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 1

Typical mileage at the time of the problem: 61,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2001 Ford E-450 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Air Bags · at 61,000 miles · reported Oct 25, 2021
The contact owns a 2001 Ford E-450. The contact stated while driving 35 MPH, the air bag warning light was illuminated. The contact stated while restarting the vehicle, the front driver’s side air bag deployed independently. The contact did not sustain any injuries nor seek medical attention. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 61,000.
Tires · at 20,500 miles · reported Aug 20, 2009
Multiple failures of nearly new nexen roadian lt tire used on two separate ford e-450 limo/shuttle chassis. Four failures were experienced within a 6 month period, and included cord/tread/inner liner separation, bulging and related failures. One failure resulted in a blow-out at speed, one failure resulted in a serious and/or catastrophic bulge/separation, and the remaining failures were similar, but caught prior to becoming dangerous. The remaining two tires were replaced/discarded w/o observed failure. All tires were replaced. One experienced, heavy truck repair and mobile truck tire service…
Service Brakes, Hydraulic · at 19,750 miles · reported Aug 16, 2006
For an unknown reason my 2001 ford e450 ABS light came on stayed on after I started my motorhome. The unit was parked for 4 days prior to this problem. The light didn't come one while driving to the location, only after being parked for the four days.
Tires · at 28,500 miles · reported Aug 8, 2006
I just had a tire blowout/tread separation on a 2001 ford e450 rv. The vehicle has 28000 miles and the treads show little wear. The tires are firestone steeltex radial r4s II lt225/75 r 16 load range e. Upon inspection of the other tires, notices cracks on the sidewalls of all the remaining tires and a bubble on the sidewall of one tire. What are my actions in regards to replacement of these tires? Thanks.
Engine and Engine Cooling · at 95,356 miles · reported Nov 19, 2005
This is an update to odi #10143249. Driving on i70 in denver, blew another spark plug out of the cylinder head. This time it stripped all the threads out. 2) caused a cost of tow and repairs. 3) service repair did a hielarch (Sp?) on the spark plug sleeve. Total incurred cost = $631.30.

Other Ford E-450 years

20272026202420232022202120192018201720162015201420132012201120102009200820072006200520042003200220012000

Compare all Ford E-450 years · All Ford models

Frequently asked questions

Does the 2001 Ford E-450 have any recalls?

Yes — NHTSA lists 2 recalls for the 2001 Ford E-450: 09V-399 (vehicle speed control), 06V-286 (vehicle speed control). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2001 Ford E-450?

Owners report tires problems most often (8 reports), followed by suspension (5). The typical mileage when problems were reported is about 61,000 miles.

Are Ford recall repairs free?

Yes. Safety recall repairs are free at authorized Ford dealers, whether you are the first owner or bought the car used.