2001 Yamaha Road Star recalls and problems

The 2001 Yamaha Road Star has 2 safety recalls and 57 owner complaints filed with NHTSA. Recall repairs are free at any Yamaha dealer.

Recalls

Complaints

Crashes / fires

3 / 0

Injuries / deaths

14 / 0

Recalls may cover only some 2001 Yamaha Road Star vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2001 Yamaha Road Star recalls

Recall 06V-397: Power Train

Reported Oct 17, 2006 · 20,000 vehicles affected · YAMAHA MOTOR CORPORATION, USA

Problem: On certain motorcycles, certain transmission components may not meet yamaha quality-control standards, which could allow abnormal wear that eventually results in a broken retaining circlip.

Risk: If the circlip breaks, the transmission could lock up, which would also cause the rear wheel to lock up. This could result in loss of control and a crash with injury or death.

Fix: Dealers will replace certain transmission components with new ones free of charge. The recall began on october 30, 2006. Owners may contact yamaha at 1-800-88-yamaha or visit their website at www.yamaha-motor.com.

Recall 03V-309: Power Train

Reported Aug 26, 2003 · 29,139 vehicles affected · YAMAHA MOTOR CORPORATION, USA

Problem: In the transmission on certain motorcycles, the second/third pinion gear may be incorrectly machined which could cause abnormal wear that eventually results in a broken retainer circlip.

Risk: If the circlip breaks, the transmission could lock up, which would also cause the rear wheel to lock up. This could result in loss of control and a crash, possibly resulting in serious injury or death.

Fix: Yamaha will replace the transmission gears and shafts with new ones. Owner notification began on september 9, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact yamaha at 1-800-88-yamaha or visit their website at www.yamaha-motor.com.

2001 Yamaha Road Star problems reported by owners

Problem area	Reports
Power Train	49
Engine and Engine Cooling	5
Fuel System, Gasoline	4
Suspension	1
Wheels	1

Most reported parts

Power Train › Manual Transmission — 39
Power Train › Automatic Transmission — 6
Fuel System, Gasoline › Carburetor System — 3
Engine and Engine Cooling › Engine — 2
Suspension › Rear — 1
Engine and Engine Cooling › Engine › Gasoline — 1
Power Train › Driveline — 1
Power Train › Automatic Transmission › Lever and Linkage › Floor Shift — 1

Typical mileage at the time of the problem: 9,200 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2001 Yamaha Road Star complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Fuel System, Gasoline · at 17,000 miles · reported Apr 14, 2009

Fuel (Gasoline) is sprayed from rear port of carburetor. As much as 2 oz may be emitted and sprayed on hot exhaust pipes and engine. The fuel immediately vaporizes. This only seems to occur when the motorcycle is hot, then shut off and allowed to sit for approximately 15 minutes. It does not spray liquid gas if immediately started or if allowed to cool. However, there is still a frequent smell of gas. First reported in august 2008. Problem is frequent.

Power Train · reported Oct 4, 2004

Manual transmission and rear wheel locked while driving at 35 MPH. When this occurred consumer was able to maintain control of the motorcycle ,and coasted it to a complete stop without the motorcycle tipping over. This occurred due to the defect described in the rear wheel lock recall 03v309000. But this vehicle was not included in the recall due to VIN.

Power Train · at 13,000 miles · reported Jun 4, 2004

Consumer received NHTSA recall 03v 309 000 concerning transmission failure in january, 2004. Later, consumer contacted the dealer, who stated parts needed to repair the motorcycle were not available, and will not be available until mid april, at the earliest. The motorcycle was finally repaired three months after the recall was initiated. The motorcycle was picked up april 3, 2004.

Power Train · at 3,300 miles · reported May 11, 2004

On january 14 2003 consumer received a recall letter regarding transmission. Dealership did not have the parts available to conduct recall repairs. Dealer was contacted, and dealer indicated that the consumer should wait a little longer.

Power Train · reported Apr 30, 2004

Nhtsa recall 03v309000. The driver contacted the dealer on january 09, 2004. The mechanic informed the consumer that the parts were not available. The mechanic couldn't inform the consumer when the parts would be available.

Other Yamaha Road Star years

2007 2006 2004 2003 200220012000

Compare all Yamaha Road Star years · All Yamaha models

Frequently asked questions

Does the 2001 Yamaha Road Star have any recalls?

Yes — NHTSA lists 2 recalls for the 2001 Yamaha Road Star: 06V-397 (power train), 03V-309 (power train). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2001 Yamaha Road Star?

Owners report power train problems most often (49 reports), followed by engine and engine cooling (5). The typical mileage when problems were reported is about 9,200 miles.

Are Yamaha recall repairs free?

Yes. Safety recall repairs are free at authorized Yamaha dealers, whether you are the first owner or bought the car used.