2002 Volvo VN recalls and problems
The 2002 Volvo VN has 5 safety recalls. Recall repairs are free at any Volvo dealer.
Recalls may cover only some 2002 Volvo VN vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2002 Volvo VN recalls
Recall 12V-510: Seat Belts
Problem: Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Risk: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Fix: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Recall 04V-457: Visibility
Problem: On certain trucks equipped with valeo wiper systems, the wiper motor may be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Risk: If this occurs, excessive heat and smoke could result in an under hood fire.
Fix: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on november 1, 2004. Owners should contact volvo trucks at 1-800-528-6586.
Recall 04V-315: Trailer Hitches
Problem: On certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged.
Risk: This condition could cause the fifth wheel latch to release inadvertently when the park brake is engaged, creating the potential for loss of the trailer. A crash could occur without prior warning.
Fix: Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on august 9, 2004. Owners should contact volvo at 1-800-528-6586.
Recall 04V-077: Engine and Engine Cooling
Problem: On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
Risk: The engine pre-heater could overheat resulting in damage to the pre-heater and other engine heat sensitive components near the pre-heater and the ability to re-start the engine could be compromised, increasing the risk of a crash.
Fix: Dealers will repair the affected circuits in the jumper wiring harness connector. Owner notification is expected to begin during march 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
Recall 02V-317: Suspension
Problem: On certain heavy duty class 8 trucks with volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
Risk: This condition could result in loss of axle stability, increasing the risk of a crash.
Fix: Dealers will replace the upper axle seat on both rear drive axles. Owner notification began january 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
Other Volvo VN years
Frequently asked questions
Does the 2002 Volvo VN have any recalls?
Yes — NHTSA lists 5 recalls for the 2002 Volvo VN: 12V-510 (seat belts), 04V-457 (visibility), 04V-315 (trailer hitches), 04V-077 (engine and engine cooling), 02V-317 (suspension). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are Volvo recall repairs free?
Yes. Safety recall repairs are free at authorized Volvo dealers, whether you are the first owner or bought the car used.