2002 International 9200I recalls and problems
The 2002 International 9200I has 4 safety recalls. Recall repairs are free at any International dealer.
Recalls may cover only some 2002 International 9200I vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2002 International 9200I recalls
Recall 23V-353: Exterior Lighting
Problem: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Fix: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
Recall 04V-307: Electrical System
Problem: On certain heavy duty trucks, the engine electrical harness can chafe against sharp edges on the engine.
Risk: Sudden acceleration, activation of the engine compression brake, engine speed dropping to idle, alternator overload with possible fire, and a loss of engine ECM power resulting in engine shutdown could occur without warning.
Fix: Dealers will inspect the harness to determine if it is damaged. If damaged, the engine harness will be repaired. All harnesses will be re-routed and stand-off brackets will be added. The recall began on september 8, 2004. Owners can contact international at 1-800-448-7825.
Recall 04V-100: Equipment
Problem: On certain conventional trucks equipped with pro-sleeper berths, water intrusion can be found in the bunk control panel area and pool in the tops of the dome light, tv/vcr, and or refrigerator power switches.
Risk: The circuit boards in the switches could heat up , possibly produce a flame or fire, and cause property damage, personal injury, or death.
Fix: Dealers will install a water shield over the back of the entire bunk control panel. Owner notification began on july 16, 2004. Owners should contact international at 1-800-448-7825.
Recall 03V-220: Trailer Hitches
Problem: On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Risk: If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash
Fix: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616-846-7700 or by email to recall@jostinternational.com or international at 1-800-448-7825.
Other International 9200I years
Compare all International 9200I years · All International models
Frequently asked questions
Does the 2002 International 9200I have any recalls?
Yes — NHTSA lists 4 recalls for the 2002 International 9200I: 23V-353 (exterior lighting), 04V-307 (electrical system), 04V-100 (equipment), 03V-220 (trailer hitches). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are International recall repairs free?
Yes. Safety recall repairs are free at authorized International dealers, whether you are the first owner or bought the car used.