2003 Gillig LOW Floor recalls and problems
The 2003 Gillig LOW Floor has 9 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Gillig dealer.
Recalls may cover only some 2003 Gillig LOW Floor vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2003 Gillig LOW Floor recalls
Recall 18V-418: Exterior Lighting
Problem: Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: The reduced visibility of the turn signals can increase the risk of a crash.
Fix: Gillig will notify owners, and dealers will update the software that controls the turn flash rate, free of charge. The recall began on August 2, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Recall 17V-119: Exterior Lighting
Problem: Gillig LLC (Gillig) is recalling certain model year 1997-2017 Low Floor transit buses. The front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: The reduced visibility of the turn signals may increase the risk of a crash.
Fix: Gillig will notify owners, and dealers will install turn signals that have increased visibility. The recall began June 7, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Recall 09V-368: Interior Lighting
Problem: Gillig corporation is recalling certain model year 2001 through 2009 transit buses manufactured between january 2001 and september 2009 equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.
Risk: A short could occur, possibly causing smoke and fire.
Fix: Gillig will notify owners and luminator will repair the buses free of charge. The safety recall began on spetember 29, 2009. Owners may contact luminator at 1-972-516-3033 or gillig field services at 1-800-735-1500.
Recall 06V-427: Fuel System, Diesel
Problem: On certain transit buses built with cummins isl and isc diesel engines equipped with the cm850 fuel system, the engine high pressure fuel lines, from the engine high pressure pump to the engine fuel rail, are prone to failure.
Risk: Failure of the line introduces high pressure fuel spray into the engine compartment which can ignite when it comes in contact with a hot surface.
Fix: Cummins will install a fuel line bracket to reduce fuel line stress. A new fuel line will be installed when adding the bracket (Please see 06e037). Gillig notified customers on november 22, 2006. Customers may contact cummins at 1-800-343-7357 or gillig at 510-264-5031.
Recall 05V-473: Engine and Engine Cooling
Problem: On certain transit buses manufactured with detroit diesel series 50 engines, the electronic control module (Ecm) will need to be reprogrammed to activate the exhaust temperature sensor.
Risk: Engine malfunction could possible lead to engine and vehicle damage and potential for a vehicle fire.
Fix: Gillig is working with detroit diesel to reprogram the engines. Gillig issued a renotification letter to owners on february 27, 2007. Owners may contact detroit diesel at 1-313-592-5791 or gillig at 1-510-785-1500.
Recall 04V-500: Equipment Adaptive/Mobility
Problem: Certain gillig buses equipped with sure-lok wheelchair tie-down securement assemblies. The sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
Risk: In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
Fix: Dealers will inspect and replace the wheelchair securement retractors as necessary. The recall began october 8, 2004. Owners should contact gillig at 1-800-735-1500..
Recall 04V-486: Engine and Engine Cooling
Problem: On certain transit buses equipped with detroit diesel series 40 engines, the turbocharger can fail allowing lubricating oil to spill onto the engine.
Risk: This can result in a fire in the engine compartment.
Fix: Dealers will inspect and replace the turbocharger to prevent the possibility of an engine compartment fire. Detroit diesel is conducting owner notification and remedy for this campaign. Gillig issued a renotification letter to owners on february 27, 2007. Owners should contact detroit detroit diesel at 313-5923708 or gillig at 510-785-1500.
Recall 04V-485: Engine and Engine Cooling
Problem: On certain phantom and low floor transit buses equipped with cummins 8.3l and 8.9l isc and isl diesel engines, oil can leak into the engine compartment from a crack in the cup plug.
Risk: Oil leakage on a hot engine can result in an engine compartment fire, possibly resulting in injuries.
Fix: Cummins will conduct the owner notification and remedy for this campaign. Cummins will isntall a steel cup plug boss cap on the affected engines. Owners should contact cummins customer assistance center at 1-800-343-7357 or gillig at 510-785-1500.
Recall 04V-308: Fuel System, Other
Problem: Certain low floor buses powered by a gaseous hydrogen fuel system. These transducers were made of 17-4 ph stainless steel material which may be susceptible to embrittlement in a high-pressure hydrogen application environment.
Risk: Embrittlement could potentially lead to a transducer diaphragm failure.
Fix: Dealers will replace the transducer. The recall began july 12, 2004. Owners should contact gillig at 1-510-785-1500.
2003 Gillig LOW Floor problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Exterior Lighting | 1 |
Most reported parts
- Exterior Lighting › Turn Signal — 1
Typical mileage at the time of the problem: 1 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Other Gillig LOW Floor years
Frequently asked questions
Does the 2003 Gillig LOW Floor have any recalls?
Yes — NHTSA lists 9 recalls for the 2003 Gillig LOW Floor: 18V-418 (exterior lighting), 17V-119 (exterior lighting), 09V-368 (interior lighting), 06V-427 (fuel system, diesel), 05V-473 (engine and engine cooling) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2003 Gillig LOW Floor?
Owners report exterior lighting problems most often (1 reports). The typical mileage when problems were reported is about 1 miles.
Are Gillig recall repairs free?
Yes. Safety recall repairs are free at authorized Gillig dealers, whether you are the first owner or bought the car used.