2005 Dodge Caravan recalls and problems
The 2005 Dodge Caravan has 4 safety recalls and 537 owner complaints filed with NHTSA. Recall repairs are free at any Dodge dealer.
Recalls may cover only some 2005 Dodge Caravan vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Dodge Caravan recalls
Recall 10V-008: Air Bags
Problem: Chrysler is recalling certain model year 2005-2006 dodge caravan, grand caravan and chrysler town & country vehicles originally sold in or currently registered in the states of connecticut, delaware, iowa, illinois, indiana, kansas, kentucky, massachusetts, maine, maryland, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, west virginia, wisconsin, alaska and the district of columbia. The front crash sensors may crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the airbag warning light. These sensors were added to enhance the performance of the airbag system in certain frontal crashes.
Risk: If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags may not provide the enhanced protection in the event of a crash.
Fix: Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during june 2010. Owners may contact chrysler at 1-800-853-1403.
Recall 07V-192: Air Bags
Problem: Certain minivans are being recalled that were originally sold in or currently registered in the 27 states plus the district of columbia that use greater amounts of salt for winter road deicing. The up-front (Uf) air bag sensors that contain brass bushings installed in these vehicles may corrode and crack allowing water to enter the sensor. These sensors provide enhanced air bag performance in certain types of frontal crashes.
Risk: In one of these crashes, with one or both of the vehicle's uf sensors inoperative, the occupants will not benefit from the enhanced air bag protection that these sensors would provide.
Fix: For vehicles registered in the recall states, dealers will replace the original uf air bag sensors with ones with greater corrosion resistance. Vehicles registered in other states will obtain a lifetime free replacement of any uf sensor that fails. The campaign began on july 2, 2007. Owners may contact daimlerchrysler at 1-800-853-1403.
Recall 06V-067: Visibility
Problem: On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break.
Risk: During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash.
Fix: Dealers will inspect and replace the windshield wiper motor free of charge. The recall began on june 19, 2006, to dodge durango owners. Minivan owners will be notified during july 2006. Owners may contact daimlerchrysler at 1-800-853-1403.
Recall 04V-047: Seat Belts
Problem: After performing the ncap test, it was discovered that on certain minivans equipped without the available "stow 'n go" seating option, the right front seat belt retractor assembly may have been improperly assembled.
Risk: As a result, the seat belt may not properly restrain the occupant during certain crash conditions, which can increase the risk of injury.
Fix: Dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. Owner notification began on february 23, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
2005 Dodge Caravan problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Latches/Locks/Linkages | 203 | |
| Electrical System | 125 | |
| Exterior Lighting | 91 | |
| Air Bags | 49 | |
| Steering | 29 | |
| Fuel/Propulsion System | 22 | |
| Suspension | 19 | |
| Power Train | 15 | |
| Service Brakes, Hydraulic | 15 | |
| Structure | 15 | |
| Visibility | 14 | |
| Engine and Engine Cooling | 14 |
Most reported parts
- Air Bags › Frontal › Sensor/Control Module — 17
- Latches/Locks/Linkages › Doors › Latch — 10
- Exterior Lighting › Headlights — 9
- Air Bags › Frontal — 8
- Power Train › Automatic Transmission — 6
- Vehicle Speed Control › Accelerator Pedal — 6
- Exterior Lighting › Headlights › Switch — 6
- Structure › Body › Door — 6
Typical mileage at the time of the problem: 64,826 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Dodge Caravan complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Dodge Caravan years
Frequently asked questions
Does the 2005 Dodge Caravan have any recalls?
Yes — NHTSA lists 4 recalls for the 2005 Dodge Caravan: 10V-008 (air bags), 07V-192 (air bags), 06V-067 (visibility), 04V-047 (seat belts). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Dodge Caravan?
Owners report latches/locks/linkages problems most often (203 reports), followed by electrical system (125). The typical mileage when problems were reported is about 64,826 miles.
Are Dodge recall repairs free?
Yes. Safety recall repairs are free at authorized Dodge dealers, whether you are the first owner or bought the car used.