2005 Chrysler Pacifica recalls and problems

The 2005 Chrysler Pacifica has 2 safety recalls and 1,244 owner complaints filed with NHTSA. Recall repairs are free at any Chrysler dealer.

Recalls

Complaints

1,244

Crashes / fires

25 / 13

Injuries / deaths

19 / 0

Recalls may cover only some 2005 Chrysler Pacifica vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2005 Chrysler Pacifica recalls

Recall 06V-432: Power Train

Reported Nov 9, 2006 · 127,928 vehicles affected · DAIMLERCHRYSLER CORPORATION

Problem: On certain passenger vehicles, the fuel pump module and the power train control module (Pcm) software may allow the engine to stall under certain operating conditions.

Risk: This could cause a crash to occur without prior warning.

Fix: Dealers will reprogram the power train control module. The fuel pump module will also be replaced on vehicles built from august 1, 2004 through september 30, 2004. The recall began on november 21, 2006. Owners may contact daimlerchrysler at 1-800-853-1403.

Recall 05V-066: Exterior Lighting

Reported Mar 1, 2005 · 43,180 vehicles affected · DAIMLERCHRYSLER CORPORATION

Problem: Certain sport utility vehicles equipped with halogen headlamps may experience an intermittent and eventual total loss of headlamp function.

Risk: The head lights may not operate properly which could result in intermittent or no headlight function. This could impair a driver's visibility, increasing the risk of a crash.

Fix: Dealers will inspect, and replace if necessary, the wiring harness and low beam bulb on both headlamp assemblies free of charge. The recall began on march 28, 2005. Owners may contact daimlerchrysler at 1-800-853-1403.

2005 Chrysler Pacifica problems reported by owners

Problem area	Reports
Structure	416
Engine	224
Engine and Engine Cooling	211
Suspension	189
Power Train	132
Electrical System	96
Unknown or Other	87
Fuel System, Gasoline	59
Vehicle Speed Control	58
Steering	55
Service Brakes, Hydraulic	50
Fuel/Propulsion System	41

Most reported parts

Structure › Body — 219
Structure › Frame and Members › Underbody Shields — 71
Engine and Engine Cooling › Engine — 53
Structure › Frame and Members — 26
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 23
Power Train › Automatic Transmission — 20
Power Train › Automatic Transmission › Control Module (Tcm/Pcm/Tecm) — 16
Fuel System, Gasoline › Delivery › Fuel Pump — 13

Typical mileage at the time of the problem: 97,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2005 Chrysler Pacifica complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine · reported Jun 5, 2026

2005 Chrysler Pacifica was purchased from a friendâs grandfather who kept the car garaged the car is literally like new inside and out the under carriage looks like new no rust I was impressed but had a rattling in the front end I figured it was a strut took it in to have struts and all front end parts replaced to my surprise I get a call from the shop engine cradle and it bushings rusted out tried buying a replacement unavailable after doing some digging itâs a common problem among the Pacifica Iâm afraid to drive it was told when it completely fails itâs going to be catastrophic…

Steering · reported Sep 2, 2023

Engine cradle rusted out! Safety risk. Had replaced. Never told by chrysler that it would rust out. Now the steering wheel wonât move! Power steering fluid full. Cannot drive it. Iâm a 72yo woman with cancer, no family, cannot afford expensive repairs. I need my car repaired.

Power Train · at 73,000 miles · reported Jul 5, 2023

The contact owns a 2005 Chrysler Pacifica. The contact stated that upon start the vehicle, the gear shifter failed to operate as needed without warning. The contact called and informed several dealers of the failure and was informed that there was a defect with the power train. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 73,000.

Unknown or Other · reported Jun 24, 2023

Engine cradle,motor mount and sub frame completely rotted out. structural integrity at a total loss. Vehicle is no longer road worthy. This problem Chrysler is continuing to ignore is definitely Hazardous for other vehicles and their occupants if catastrophic failure of the above named components were to occur while driving even at normal operating speeds. How many complaints have to be made about this failure of design before something is done? how many people have to endure hardship over loss of transportation due to having repairs done, figuring out ways to cover costs or total loss of…

Unknown or Other · reported Mar 13, 2023

Driving normally when vehicle shut off and rear of engine burst into flame. It seems multiple people have had this problem.

Other Chrysler Pacifica years

2027 2026 2025 2024 2023 2022 2021 2020 2019 2018 2017 2008 2007 200620052004

Compare all Chrysler Pacifica years · All Chrysler models

Frequently asked questions

Does the 2005 Chrysler Pacifica have any recalls?

Yes — NHTSA lists 2 recalls for the 2005 Chrysler Pacifica: 06V-432 (power train), 05V-066 (exterior lighting). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2005 Chrysler Pacifica?

Owners report structure problems most often (416 reports), followed by engine (224). The typical mileage when problems were reported is about 97,000 miles.

Are Chrysler recall repairs free?

Yes. Safety recall repairs are free at authorized Chrysler dealers, whether you are the first owner or bought the car used.