2011 Chevrolet Express 1500 recalls and problems

The 2011 Chevrolet Express 1500 has 2 safety recalls and 3 owner complaints filed with NHTSA. Recall repairs are free at any Chevrolet dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2011 Chevrolet Express 1500 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2011 Chevrolet Express 1500 recalls

Recall 11V-275: Service Brakes, Hydraulic

Reported May 6, 2011 · 7,593 vehicles affected · GENERAL MOTORS LLC

Problem: General motors is recalling certain model year 2011 chevrolet express and gmc savana vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 135, "passenger car brake systems." some of these vehicles may have been built with a clearance condition in which the right rear brake hose may contact the tire or wheel rim. If the brake hose repeatedly contacts the tire or wheel rim, a hole could be worn in the brake hose.

Risk: A damaged brake hose may reduce the effectiveness of the rear brakes and increase the distance required to stop the vehicle. An increased braking distance may increase the risk of a crash.

Fix: Dealers will secure the right rear brake hose to ensure sufficient clearance. This service will be performed free of charge. The safety recall began on may 13, 2011. Owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 or www.gmownercenter.com.

Recall 11V-007: Suspension

Reported Jan 6, 2011 · 30,566 vehicles affected · GENERAL MOTORS CORP.

Problem: General motors is recalling certain model year 2011 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, colorado, express, silverado, suburban, tahoe; and gmc canyon, sierra, savana, yukon and yukon xl vehicles. The rear axle cross pins were not properly heat treated and could fracture and become displaced within the rear axle. Should the pin shift out of position, it could create an interference condition and cause the rear axle to lock.

Risk: The driver may not be able to maintain directional control of the vehicle and a crash could occur without warning.

Fix: Dealers will install a new rear axle cross pin free of charge. The safety recall began on january 11, 2011. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 and at the owner center at www.gmownercenter.com.

2011 Chevrolet Express 1500 problems reported by owners

Problem area	Reports
Exterior Lighting	1
Service Brakes	1
Air Bags	1

Typical mileage at the time of the problem: 80,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2011 Chevrolet Express 1500 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Air Bags · at 80,000 miles · reported Mar 20, 2020

My air bag warning light came on and when I investigated I found it was probably related to the front air bag sensors. When I examined the sensors I found that the aluminum alloy body and the plastic shield surrounding it had split wide apart where the steel mounting screw passed through the sensor housing. Both sensors have failed in exactly the same manor. The vehicle has 83,000 miles on it and does not have any other of advanced corrosion anywhere else. I contacted GM and they seemed to have no interest and advised me to take it to a dealer and have it repaired at my own expense.

Service Brakes · at 87,000 miles · reported Jan 31, 2020

We developed a significant leak in a rear brake line of our van. The leak did not lead to a loss of control, but the brake reservoir was nearly empty when I discovered the issue. The leak was discovered based on a large spot left on our driveway under the van. The vehicle was probably driven about 50-100 miles (One to two days) after the leak developed but before the issue was discovered and addressed. While fixing the problem, I found that the leak was due to an assembly error. The van's fuel filler down-pipe has a worm-gear clamp that was not properly clocked. This caused the clamp to rub…

Exterior Lighting · at 12,000 miles · reported May 9, 2019

The contact owns a 2011 chevrolet express 1500 cargo van. The contact stated that the low beam head lamps had failed on five separate occasions. The vehicle was taken to an independent mechanic who replaced the head lamps each time. The cause of the failures were not determined. The local dealer was not contacted. The manufacturer was notified of the failures but no assistance was offered. The failure mileage was 12,000. Consumer stated sealed beam lamps on both sides were replaced mulitple times. Vin is invalid.

Other Chevrolet Express 1500 years

201420112010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000

Compare all Chevrolet Express 1500 years · All Chevrolet models

Frequently asked questions

Does the 2011 Chevrolet Express 1500 have any recalls?

Yes — NHTSA lists 2 recalls for the 2011 Chevrolet Express 1500: 11V-275 (service brakes, hydraulic), 11V-007 (suspension). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2011 Chevrolet Express 1500?

Owners report exterior lighting problems most often (1 reports), followed by service brakes (1). The typical mileage when problems were reported is about 80,000 miles.

Are Chevrolet recall repairs free?

Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.