There are no safety recalls for the 2006 Chevrolet Express 1500, but owners have filed 5 complaints with NHTSA.
2006 Chevrolet Express 1500 problems reported by owners
| Problem area | Reports | |
|---|
| Unknown or Other | 2 | |
| Fuel System, Gasoline | 1 | |
| Latches/Locks/Linkages | 1 | |
| Structure | 1 | |
| Fuel System, Other | 1 | |
Typical mileage at the time of the problem: 41,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Chevrolet Express 1500 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Unknown or Other · reported Nov 9, 2020
The vehicle security light comes on intermittently for years, I then cannot start the vehicle. I have reported the problem to GM, I have had it to the chevrolet dealership twice, which cost me over a thousand dollars for them to replace parts which had no effect in solving the problem. The vehicle will not start until you turn the key to the on position, wait 10 minutes for the light to go out, then turn off the ignition for 10 seconds, then it will start. I have put up with it for years, but when I AM stranded in the dead of winter, that poses a safety hazard. Your report wants to know when…
Fuel System, Other · at 41,000 miles · reported Nov 17, 2009
Faulty fuel gauge sensor on 2006 chevy express van. My fuel gauge read approx 1/8th of a tank. The low fuel light had not come on. The van stopped running and could not be started. It was towed to nucar in new castle. Sensor and fuel pump were replaced as the dealer said they would not guarantee the sensor without replacing the fuel pump. The cost > $1,000. I read your article and now friends of mine have experienced similar problems.
Latches/Locks/Linkages · at 24,000 miles · reported Oct 4, 2009
The hinges on the doors of chevy vans are defective in that they are improperly designed and corroded and become difficult if not impossible to open and close the hinges are inverted and allow dirt and water to invade the swivel portion of the hinge I have reported this to the dealers are three occasions and they basically said tuff luck they were aware of the problem when I went in they say additional maintenance is required but make no mention of it nor do they do anything special at their facility I have had my vehicles serviced there and it makes no difference.
Fuel System, Gasoline · at 64,000 miles · reported Jan 11, 2009
Driving along the highway, my warning light came on stating there was an engine problem. I waited to get it checked out. As I was making a delivery the 2006 express cargo stalled on the highway. Had it towed to the chevrolet dealership and they stated it was the fuel sensor in the gas tank that burnt out.
Frequently asked questions
Does the 2006 Chevrolet Express 1500 have any recalls?
No. NHTSA has no safety recalls for the 2006 Chevrolet Express 1500 as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2006 Chevrolet Express 1500?
Owners report unknown or other problems most often (2 reports), followed by fuel system, gasoline (1). The typical mileage when problems were reported is about 41,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.