2019 Blue Bird Vision recalls and problems
The 2019 Blue Bird Vision has 41 safety recalls. Recall repairs are free at any Blue Bird dealer.
Recalls may cover only some 2019 Blue Bird Vision vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2019 Blue Bird Vision recalls
Recall 24V-758: Equipment
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."
Risk: An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Fix: Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).
Recall 24V-599: Fuel System, Gasoline
Problem: Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.
Recall 24V-600: Fuel System, Gasoline
Problem: Blue Bird Bus Company (Blue Bird) is recalling certain 2018-2021 Vision transit buses equipped with 6.8L gasoline engines. The coating on the fuel lines may have been improperly applied, which can result in a fuel leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Dealers will inspect and replace the fuel lines as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.
Recall 24V-543: Structure
Problem: Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Risk: Roof panels that separate during a crash can increase the risk of injury.
Fix: Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.
Recall 23V-276: Power Train
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All American and Vision School Buses, equipped with PowerDrive 7000 electric drive systems. The System Control Module (SCM) may activate the anti-rollback feature, causing the vehicle to reverse faster than expected when the vehicle is in reverse and pointing downhill with the brake pedal not applied.
Risk: A vehicle reversing faster than expected can increase the risk of a crash.
Fix: Dealers will update the SCM software calibration, free of charge. Owner notification letters were mailed May 10, 2023. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CG (SB)
Recall 22V-736: Fuel System, Other
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2013-2021 Vision school buses equipped with Ford 6.8L LPG engines. The LPG supply line may be damaged from contact with the RH park brake cable, which can result in a fuel leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Dealers will inspect and repair the fuel lines and the park brake cable, free of charge. Owner notification letters were mailed on November 18, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22CA-SB.
Recall 22V-579: Fuel System, Other
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2017-2023 Blue Bird Vision school buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.
Risk: A corroded fuel line can leak fuel, increasing the risk of a fire.
Fix: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-SB.
Recall 22V-578: Fuel System, Other
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.
Risk: A corroded fuel line can leak fuel, increasing the risk of a fire.
Fix: Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-NSB.
Recall 22V-505: Electrical System
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.
Risk: An improperly grounded air compressor can cause electric shock, increasing the risk of injury.
Fix: Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.
Recall 21V-300: Power Train, Steering
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The drivetrain may experience an electromagnetic noise on the Control Area Network (CAN) bus, which may cause a loss of electrical power to the power steering pump.
Risk: A loss of assisted power steering increases the risk of a crash.
Fix: Cummins will replace the High Voltage Low Power Inverter Harness, and install an overlay harness, free of charge. Interim owner notification letters were mailed on May 22, 2021. Owner notification letters were mailed on October 25, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242.
Recall 21V-253: Electrical System
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The electric drive train cannot detect isolation faults when the high voltage contactors are closed.
Risk: An undetected high voltage isolation can expose service personnel to high voltage, increasing the risk of injury.
Fix: Blue Bird will notify owners, and dealers will update the Vehicle Control Unit software or install a different combination of High Voltage Power Distribution Unit hardware, free of charge. The recall began on May 22, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BD-SB.
Recall 21V-070: Seat Belts
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Risk: An incorrectly installed seat can increase the risk of injury in the event of a crash.
Fix: Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BB-SB.
Recall 20V-407: Seat Belts
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Vision and All-American transit buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk: In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.
Fix: Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. The recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX-NSB.
Recall 20V-409: Seat Belts
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All-American and 2019-2021 Vision school buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk: In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.
Fix: Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. This recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX.
Recall 20V-356: Steering
Problem: Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 Blue Bird Vision school buses powered by Compressed Natural Gas (CNG) or Liquefied Petroleum Gas (LPG). The castle nuts used to connect the steering drag link to the steering arm may have not been correctly tightened, potentially causing separation of the drag link.
Risk: If the drag link separates, loss of steering control my occur, increasing the risk of a crash.
Fix: Blue Bird will notify owners, and will inspect the drag link assembly connection points, tightening them as necessary, free of charge. This recall began July 27, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AW-SB.
Older recalls
| Recall | Date | Component | Summary |
|---|---|---|---|
| 20V-249 | May 5, 2020 | Fuel System, Gasoline, Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision school buses equipped with Ford 6.8L gasoline engines with an optional right-hand mounted parking brake lever. |
| 20V-234 | Apr 27, 2020 | Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2006-2021 Vision and 2007-2013 All American school buses. |
| 20V-235 | Apr 27, 2020 | Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2009-2019 Vision transit buses. |
| 20V-125 | Mar 3, 2020 | Seats | Blue Bird Body Company (Blue Bird) is recalling certain 2008-2021 Vision and All American school buses. |
| 20V-074 | Feb 11, 2020 | Power Train | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with 7000 EV electric drivetrain units. |
| 19V-796 | Nov 6, 2019 | Exterior Lighting | Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision transit buses equipped with Ford engines. |
| 19V-795 | Nov 6, 2019 | Exterior Lighting | Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Vision school buses equipped with Ford engines. |
| 19V-765 | Oct 25, 2019 | Power Train, Hybrid Propulsion System | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with Cummins PowerDrive 7000 EV electric drivetrain units. |
| 19V-707 | Oct 4, 2019 | Structure | Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 All American and Vision school buses. |
| 19V-526 | Jul 12, 2019 | Structure | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2020 Vision and All American school buses equipped with Specialty Manufacturing Prolo roof emergency exit hatches. |
| 19V-471 | Jun 19, 2019 | Electrical System, Hybrid Propulsion System | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Vision and All American school buses equipped with PowerDrive 7000 EV electric drivetrains. |
| 19V-393 | May 24, 2019 | Service Brakes, Air | Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Vision and 2015-2020 All American non-school buses equipped with ADB22X disc brakes. |
| 19V-391 | May 24, 2019 | Service Brakes, Air | Blue Bird Body Company (Blue Bird) is recalling certain 2015-2020 Vision and All American school buses equipped with Bendix ADB22X air brakes. |
| 19V-081 | Feb 11, 2019 | Equipment Adaptive/Mobility | Blue Bird Body Company (Blue Bird) is recalling one 2019 Blue Bird Vision bus equipped with a Ricon S-Series Titanium Wheelchair lift. |
| 19V-082 | Feb 11, 2019 | Equipment Adaptive/Mobility | Blue Bird Body Company (Blue Bird) is recalling certain 2015-2019 Vision and All American school buses equipped with Ricon S-Series Titanium Wheelchair lifts. |
| 18V-892 | Dec 17, 2018 | Engine and Engine Cooling, Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses equipped with Cummins ISV5.0 diesel engines with optional CP80009 air compressors. |
| 18V-884 | Dec 12, 2018 | Power Train, Service Brakes, Hydraulic | Blue Bird Body Company (Blue Bird) is recalling certain 2013-2020 Blue Bird Vision school buses equipped with the Ford 6.8L V10 engines. |
| 18V-885 | Dec 12, 2018 | Power Train, Service Brakes, Hydraulic | Blue Bird Body Company (Blue Bird) is recalling certain 2016-2020 Blue Bird Vision transit buses equipped with the Ford 6.8L V10 engines. |
| 18V-880 | Dec 11, 2018 | Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision school buses. |
| 18V-881 | Dec 11, 2018 | Parking Brake | Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and Vision transit buses. |
| 18V-846 | Nov 28, 2018 | Seats | Blue Bird Body Company (Blue Bird) is recalling certain 2020 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain HSM NextGen 45" 3PT school bus seats, part number GenQ3-45 LH. |
| 18V-783 | Nov 6, 2018 | Electrical System | Blue Bird Body Company (Blue Bird) is recalling certain 2017-2019 Vision school buses with Ford 6.8L Gen IV LPG, Gasoline, or CNG engines. |
| 18V-566 | Aug 28, 2018 | Equipment, Seats | Blue Bird Body Company (Blue Bird) is recalling certain 2019 Blue Bird All American and 2019-2020 Blue Bird Vision school buses, equipped with certain NextGen School Bus seats with Integrated Child Restraint Systems. |
| 18V-263 | Apr 25, 2018 | Electrical System, Service Brakes, Air | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision school buses. |
| 18V-264 | Apr 25, 2018 | Electrical System, Service Brakes, Air | Blue Bird Body Company (Blue Bird) is recalling certain 2018-2019 Blue Bird All American and Vision transit buses. |
| 17V-510 | Aug 17, 2017 | Seats | Blue Bird Body Company (Blue Bird) is recalling certain model year 2015-2019 Vision and model year 2016 All American school buses equipped with certain QS11 series convertible school bus seats supplied by CE White/HSM… |
Other Blue Bird Vision years
Frequently asked questions
Does the 2019 Blue Bird Vision have any recalls?
Yes — NHTSA lists 41 recalls for the 2019 Blue Bird Vision: 24V-758 (equipment), 24V-599 (fuel system, gasoline), 24V-600 (fuel system, gasoline), 24V-543 (structure), 23V-276 (power train) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are Blue Bird recall repairs free?
Yes. Safety recall repairs are free at authorized Blue Bird dealers, whether you are the first owner or bought the car used.