2004 Yamaha FJR1300 recalls and problems

The 2004 Yamaha FJR1300 has 1 safety recall and 7 owner complaints filed with NHTSA. Recall repairs are free at any Yamaha dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

1 / 0

Recalls may cover only some 2004 Yamaha FJR1300 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 Yamaha FJR1300 recalls

Recall 06V-371: Vehicle Speed Control

Reported Sep 28, 2006 · 39,757 vehicles affected · YAMAHA MOTOR CORPORATION, USA

Problem: On certain motorcycles, an improperly designed throttle position sensor could cause an intermittently unstable idle when the engine is at idling speed when the motorcycle is stopped or during low-speed operations. The engine could stall as a result.

Risk: If the engine stalls after the operator disengages the clutch in a low gear while riding, the rear tire might slip momentarily if the operator abruptly re-engages the clutch. This could result in a crash with injury or death.

Fix: Dealers will replace the throttle position sensor free of charge. The recall began on october 16, 2006. Owners may contact yamaha at 1-888-88-yamaha.

2004 Yamaha FJR1300 problems reported by owners

Problem area	Reports
Electrical System	4
Engine and Engine Cooling	2
Vehicle Speed Control	1
Service Brakes	1

Typical mileage at the time of the problem: 44,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 Yamaha FJR1300 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes · at 44,000 miles · reported Oct 20, 2015

Abs brake system not functioning, rear wheel locks up when brakes are applied. Unwilling to test the front wheel ABS system. Several other occurrences of ABS system failure have been documented on the fjr forum.

Electrical System · at 45,869 miles · reported Aug 11, 2015

I stopped during a motorcycle ride to take a picture and turned the ignition key on my motorcycle to the off position. When I turned the key back to on no power was available. Repeated attempts to use the key were unsuccessful. I knew there had been a recall on subsequent years of the same model motorcycle for this problem. If this would have happened when I was in motion the engine would have immediately stopped and all electrical power to the motorcycle systems would have been lost as well.

Electrical System · at 50,123 miles · reported May 20, 2012

Took off ramp off of highway and slowed down to stop at stop light and motorcycle died. No lights, gauges, or any type off electrical power on the bike at all. Could not use flashers due to power failure. Pushed bike to side of road and with help pushed bike to gas station 1/8th mile down the road on a busy high way. After diagnosing issue found the ignition switch failed. Was able to bypass ignition switch to get back home. Glad it didn't happen on the expressway.

Electrical System · at 49,500 miles · reported Mar 26, 2012

While riding the motorcycle on a straight & level road, dry, daytime, cruising approximately 30 MPH (With my wife on back), bike suddenly and completely quit, including all instrumentation and blinkers. Luckily, I was able to safely pull over (Pulled clutch in and coasted out of lane) with traffic right on my back, as no flashers or brake lights were functioning. Thank god it didn't happen on the freeway. On the side of the road, I found all fuses good and after an hour of roadside diagnosis, got a tow truck. Bike could not be jumped either - battery was good, but 100% electrical failure.…

Electrical System · at 34,958 miles · reported Aug 25, 2010

Ignition switch failure. With no prior symptoms, ignition switch failed to turn electrical circuits on. Without power, nothing that is electrical works. Ignition switch unit replaced. Disassembly of old switch showed evidence of minor melting and distortion which prevented the primary contacts from touching in the on position.

Other Yamaha FJR1300 years

2021 2020 2019 2018 2017 2016 2015 2014 2013 2011 2009 2008 2007 2006 200520042003

Compare all Yamaha FJR1300 years · All Yamaha models

Frequently asked questions

Does the 2004 Yamaha FJR1300 have any recalls?

Yes — NHTSA lists 1 recall for the 2004 Yamaha FJR1300: 06V-371 (vehicle speed control). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 Yamaha FJR1300?

Owners report electrical system problems most often (4 reports), followed by engine and engine cooling (2). The typical mileage when problems were reported is about 44,000 miles.

Are Yamaha recall repairs free?

Yes. Safety recall repairs are free at authorized Yamaha dealers, whether you are the first owner or bought the car used.