2003 Winnebago Journey recalls and problems
The 2003 Winnebago Journey has 4 safety recalls and 5 owner complaints filed with NHTSA. Recall repairs are free at any Winnebago dealer.
Recalls may cover only some 2003 Winnebago Journey vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2003 Winnebago Journey recalls
Recall 10V-525: Equipment
Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Recall 09V-300: Equipment
Problem: Winnebago is recalling 1,547 model year 2001-2003 recreational vehicles equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.
Risk: If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Fix: Winnebago is working with norcold and norcold will notify owners and the vehicle's refrigerator will be repaired free of charge (Please see 09e-027). Owners may contact norcold's recall center at 1-800-767-9101.
Recall 04V-114: Equipment
Problem: On certain motorhomes, the LP tank has stress on weld joints at the point where mounting brackets are welded to the tank.
Risk: This could cause stress cracks at the weld joints and lead to an LP leak and cause personal injury and/or vehicle damage.
Fix: Dealers will reinstall a cradle-style carrier, and, if necessary replace the LP tank. The recall began on march 25, 2004. Owners should contact winnebago at 641-585-6939.
Recall 03V-026: Fuel System, Gasoline
Problem: On certain motor homes equipped with caterpillar 3126e hydraulically controlled electronically actuated unit injected diesel engines with high efficiency pumps (Hep8). The pump components may experience a high pressure seal failure which can result in a short period of rough running and subsequent engine stall due to a loss of injection actuation pressure.
Risk: Once engine stall occurs, the engine cannot be restarted, increasing the risk of a crash.
Fix: Caterpillar is conducting the owner notification and remedy for this campaign. Dealers will inspect the pump serial numbers and replace the pump if necessary. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact caterpillar at 1-800-447-4986 or winnebago at 1-641-585-6966.
2003 Winnebago Journey problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Engine and Engine Cooling | 2 | |
| Vehicle Speed Control | 1 | |
| Equipment | 1 | |
| Tires | 1 |
Most reported parts
- Engine and Engine Cooling › Exhaust System › Manifold/Header/Muffler/Tail Pipe — 2
- Vehicle Speed Control › Accelerator Pedal — 1
- Equipment › Recreational Vehicle/Trailer › Lpg Systems › Tank Assembly — 1
Typical mileage at the time of the problem: 18,900 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2003 Winnebago Journey complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Winnebago Journey years
Frequently asked questions
Does the 2003 Winnebago Journey have any recalls?
Yes — NHTSA lists 4 recalls for the 2003 Winnebago Journey: 10V-525 (equipment), 09V-300 (equipment), 04V-114 (equipment), 03V-026 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2003 Winnebago Journey?
Owners report engine and engine cooling problems most often (2 reports), followed by vehicle speed control (1). The typical mileage when problems were reported is about 18,900 miles.
Are Winnebago recall repairs free?
Yes. Safety recall repairs are free at authorized Winnebago dealers, whether you are the first owner or bought the car used.