2005 Winnebago Adventurer recalls and problems
The 2005 Winnebago Adventurer has 6 safety recalls and 7 owner complaints filed with NHTSA. Recall repairs are free at any Winnebago dealer.
Recalls may cover only some 2005 Winnebago Adventurer vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Winnebago Adventurer recalls
Recall 10V-525: Equipment
Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Recall 09V-113: Fuel System, Diesel
Problem: Winnebago is recalling 2,331 my 2002-2004 brave and itasca sunrise my 2005 2006 winnebago voyage, adventurer, itasca sunrise and suncruiser motor homes. The propane tank mounting bracket may have an incomplete or improper weld.
Risk: Should the weld fail, the propane tank can tip or fall, possibly releasing propane which has the potential to ignitea fire, resulting in personal injury and/or vehicle and property damage.
Fix: Dealers will inspect and properly weld the bracket free of charge. The recall is expected to begin during may 2009. Owners may contact winnebago at 800-537-1885.
Recall 05V-407: Equipment
Problem: On certain motor homes, the roof vent for the optional 4-door refrigerator was incorrectly located.
Risk: This can allow excessive heat buildup which has the potential to ignite surrounding materials, resulting in personal injury and/oi vehicle and property damage.
Fix: Dealers will relocate the roof vent. The recall began on september 9, 2005. Owners may contact winnebago at 1-641-585-6939.
Recall 05V-077: Equipment
Problem: Certain motor homes built on 24,000-lb gross vehicle weight rating (Gvwr)workhorse chassis with 235/80r22.5g xrv tires fail to comply with the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for motor vehicles other than passenger cars.' the motor homes were inadvertently equipped with an incorrect load range tire label.
Risk: Failure to follow proper vehicle loading specifications and tire inflation recommendations can result in tire damage and vehicle instability, which could result in a crash.
Fix: Owners will be mailed supplementary tire labels containing the correct tire inflation information. If an owner desires, their dealer can install the label for them. The recall began on march 24, 2005. Owners may contact winnebago at 641-585-6939.
Recall 04V-609: Fuel System, Gasoline
Problem: On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
Risk: Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.
Recall 04V-608: Seat Belts
Problem: Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Risk: The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
Fix: Dealers will replace the buckles. The recall began on november 12, 2004. Owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.
2005 Winnebago Adventurer problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Equipment | 4 | |
| Electrical System | 1 | |
| Service Brakes, Hydraulic | 1 | |
| Unknown or Other | 1 | |
| Service Brakes | 1 |
Most reported parts
- Equipment › Recreational Vehicle/Trailer — 2
Typical mileage at the time of the problem: 94,887 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Winnebago Adventurer complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Winnebago Adventurer years
Compare all Winnebago Adventurer years · All Winnebago models
Frequently asked questions
Does the 2005 Winnebago Adventurer have any recalls?
Yes — NHTSA lists 6 recalls for the 2005 Winnebago Adventurer: 10V-525 (equipment), 09V-113 (fuel system, diesel), 05V-407 (equipment), 05V-077 (equipment), 04V-609 (fuel system, gasoline) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Winnebago Adventurer?
Owners report equipment problems most often (4 reports), followed by electrical system (1). The typical mileage when problems were reported is about 94,887 miles.
Are Winnebago recall repairs free?
Yes. Safety recall repairs are free at authorized Winnebago dealers, whether you are the first owner or bought the car used.