2005 Volkswagen Touareg recalls and problems

The 2005 Volkswagen Touareg has 2 safety recalls and 75 owner complaints filed with NHTSA. Recall repairs are free at any Volkswagen dealer.

Recalls
2
Complaints
75
Crashes / fires
0 / 0
Injuries / deaths
1 / 0

Recalls may cover only some 2005 Volkswagen Touareg vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2005 Volkswagen Touareg recalls

Recall 17V-583: Fuel System, Gasoline

Reported Sep 20, 2017 · 73,941 vehicles affected · Volkswagen Group of America, Inc.

Problem: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Fix: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.

Recall 04V-592: Seat Belts

Reported Dec 15, 2004 · 50,483 vehicles affected · VOLKSWAGEN OF AMERICA, INC

Problem: Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection." all three rear seat positions and the front passenger position are equipped with seat belt retractors that have a locking feature which converts the retractor from an emergency locking retractor (Elr) mode to an automatic locking retractor (Alr) mode for the purposes of child restraint installation. The belt may deactivate the alr mode with certain child restraints.

Risk: When involved in a crash, the child restraints may not be properly secured, increasing the risk of injuries or death.

Fix: Dealers will permanently install a 'clip' in each of the two rear outboard seat belts. The clips will prevent unwanted deactivation of the alr mode with child seat installations. The recall began on april 11, 2005. Owners should contact vw at 1-800-822-8987.

2005 Volkswagen Touareg problems reported by owners

Problem areaReports
Fuel/Propulsion System16
Electrical System14
Power Train11
Tires9
Air Bags8
Seat Belts7
Fuel System, Gasoline5
Service Brakes, Hydraulic4
Exterior Lighting4
Steering4
Seats3
Structure3

Most reported parts

  • Power Train › Automatic Transmission — 5
  • Service Brakes, Hydraulic › Foundation Components › Disc › Pads — 2
  • Tires › Tread/Belt — 2
  • Seats › Front Assembly › Seat Heater/Cooler — 1
  • Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 1
  • Exterior Lighting › Headlights — 1
  • Latches/Locks/Linkages › Doors › Latch — 1
  • Seat Belts › Rear/Other — 1

Typical mileage at the time of the problem: 70,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2005 Volkswagen Touareg complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · reported Apr 28, 2026
My OBD port cannot be read. It will not communicate, or I cannot communicate with the vehicle using any OBD reading software. Myself or my mechanic. This is a major safety concern due to several reasons. Most importantly, I'm being told that it can affect, or it's probably caused by, electrical problems that are well known on this particular model and year for this maker. Something's wrong with it, where it's either being shorted somewhere, or for whatever reason, because it's not communicating. It's caused the vehicle to shut off randomly, sometimes it will allow you to restart, and then…
Fuel System, Gasoline · at 99,000 miles · reported Oct 23, 2024
The contact owns a 2005 Volkswagen Touareg. The contact stated that while driving approximately 30 MPH, the vehicle stalled. The contact pulled over and attempted to restart the vehicle, but the vehicle failed to restart. The contact stated there was no warning light illuminated. The contact had the vehicle towed to the residence. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V583000 (Fuel…
Electrical System · reported Aug 31, 2023
Due to a leak in either the sunroof or the windshield water continuously drips down every time it rains onto the floorboard of the driver side of this vehicle, creating a sopping wet floor board that has 2 inches of water, which in turn soaks the whole electrical system for this vehicle. I mean the water continuously drips from the time you purchase this vehicle until forever I guarantee that anybody who has a v8 version of the 2005 Volkswagen Touareg has a sopping wet driver, side floor board! The water never has a chance to dry, especially in colder climates Mine went into limp mode due to…
Fuel/Propulsion System · reported Aug 8, 2023
The issue explained in Recall Notice 20Ai has reappeared after being 'fixed'. Issue Summary: On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Date of Recall Repair: 02/25/2019 Date of noticed failure: 08/07/2023 It has not been communicated that this part will continue to be a hazard, and I have now discovered that even when noted that this recall action has been completed, my vehicle has gasoline leaking into the…
Electrical System · reported Feb 20, 2023
After doing major research with other owners of like year and model I have discovered that i'm not the only one that is experiencing headlight electronics or headlight electrical system within the headlight assembly frying the electrical wires, cracking the brittle wire coating and exposing many of the electrical wires together within the housing unit of the headlight Assembly. This caused many short circuits Headlights Shutting off at random times but most importantly shutting off at night on a dark highway. Depending on the bumps and bruises of the streets would cause the Wires to touch each…

Other Volkswagen Touareg years

Compare all Volkswagen Touareg years · All Volkswagen models

Frequently asked questions

Does the 2005 Volkswagen Touareg have any recalls?

Yes — NHTSA lists 2 recalls for the 2005 Volkswagen Touareg: 17V-583 (fuel system, gasoline), 04V-592 (seat belts). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2005 Volkswagen Touareg?

Owners report fuel/propulsion system problems most often (16 reports), followed by electrical system (14). The typical mileage when problems were reported is about 70,000 miles.

Are Volkswagen recall repairs free?

Yes. Safety recall repairs are free at authorized Volkswagen dealers, whether you are the first owner or bought the car used.