Home › Toyota › 4Runner › 2023

2023 Toyota 4Runner recalls and problems

The 2023 Toyota 4Runner has 1 safety recall and 33 owner complaints filed with NHTSA. Recall repairs are free at any Toyota dealer.

Recalls
1
Complaints
33
Crashes / fires
6 / 1
Injuries / deaths
5 / 0

Recalls may cover only some 2023 Toyota 4Runner vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2023 Toyota 4Runner recalls

Recall 23V-680: Equipment

Reported Oct 12, 2023 · 13 vehicles affected · Southeast Toyota Distributors, LLC

Problem: Southeast Toyota Distributors, LLC (SET) is recalling certain 2023 Toyota 4Runner vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle increases the risk of a crash.

Fix: Southeast Toyota Distributors, LLC will mail a new modified label, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET23A.

2023 Toyota 4Runner problems reported by owners

Problem areaReports
Unknown or Other12
Tires4
Exterior Lighting3
Forward Collision Avoidance3
Steering3
Suspension3
Back Over Prevention2
Seat Belts2
Service Brakes2
Air Bags2
Lane Departure2
Engine2

Most reported parts

  • Forward Collision Avoidance › Warnings — 2
  • Back Over Prevention › Rearview System Braking — 1
  • Forward Collision Avoidance › Automatic Emergency Braking — 1
  • Lane Departure › Warning — 1
  • Lane Departure › Blind Spot Detection — 1
  • Latches/Locks/Linkages › Doors › Lock — 1

Typical mileage at the time of the problem: 10,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2023 Toyota 4Runner complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Suspension · reported Oct 14, 2026
Vehicle Component: Solid Rear Axle Assembly / Rear Suspension GeometryDefect Summary: The vehicle exhibits a factory manufacturing defect causing severe rear axle misalignment. At approximately 350 miles from new, an official dealership Hunter alignment report documented out-of-spec rear alignment parameters (-0.16° rear total toe) on a non-adjustable, factory solid rear axle assembly. Safety Risk & Impact: A misaligned solid rear axle compromises vehicle stability, introduces rear thrust angle deviation, and impairs predictable vehicle tracking and emergency evasive handling at highway…
Latches/Locks/Linkages · at 77,000 miles · reported Sep 4, 2026
The contact owns a 2023 Toyota 4Runner. The contact stated that the driver's side door failed to lock using the key fob or the buttons on the door. The doors had to be manually locked and unlocked. The vehicle was taken to the dealer, where it was confirmed to be a known issue, and the locks were replaced. Shortly after the vehicle was repaired, the failure reoccurred. The vehicle was taken to the dealer, and the failure was confirmed; however, the warranty coverage only provided a repair for the driver's side door. The failure had occurred on the passenger door and the rear driver’s side…
Service Brakes · reported May 21, 2026
New, strange noise started in Dec'25 (41K miles; 2yrs 9 months). No warning lights. Diagnosed as failed brake accumulator (first at an independent shop, later at the dealer). Apparently the accumulator is part of the full master cylinder assembly which must be replaced. Toyota has quoted $3,200 to complete this repair and is telling me it must be out of pocket.
Steering · reported Mar 3, 2026
I was driving the vehicle and suddenly the steering wheel started to getting hard to turn it and the dash board doesn’t show any failure I went right away to dealership close by they inspected the vehicle they states there is a power steering failure but the car never showed any failure on dashboard or safety system
Visibility/Wiper · reported Feb 6, 2026
Windshield cracked approximately 2” from the bottom all the way across while using the defroster to clear ice from it. I was still parked at the time. I am unsure how long it will stay water tight or become worse. One concern is the crash avoidance and the automatic high beam sensor are both attached to the windshield and don’t want them to fail. I also don’t want the entire piece of glass to shatter and land in my lap while driving. The dealer refused honoring the repair under warranty. They only use one particular repair shop (which I suspect they own) and even quoted me a price for…

Other Toyota 4Runner years

202620252024202320222021202020192018201720162015201420132012201120102009200820072006200520042003200220012000

Compare all Toyota 4Runner years · All Toyota models

Frequently asked questions

Does the 2023 Toyota 4Runner have any recalls?

Yes — NHTSA lists 1 recall for the 2023 Toyota 4Runner: 23V-680 (equipment). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2023 Toyota 4Runner?

Owners report unknown or other problems most often (12 reports), followed by tires (4). The typical mileage when problems were reported is about 10,000 miles.

Are Toyota recall repairs free?

Yes. Safety recall repairs are free at authorized Toyota dealers, whether you are the first owner or bought the car used.