2005 Tiffin Phaeton recalls and problems
The 2005 Tiffin Phaeton has 5 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Tiffin dealer.
Recalls may cover only some 2005 Tiffin Phaeton vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Tiffin Phaeton recalls
Recall 11V-082: Equipment
Problem: Tiffin motorhomes is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Tiffin motorhomes is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The safety recall began on february 17, 2011. Owners may contact norcold at 1-800-767-9101.
Recall 08V-509: Equipment
Problem: Tiffin is recalling 3,507 my 2004-2007 allegro, allegro bay and allero bus, my 2004-2005 phaeton and my 2005-2007 zephyr motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (Gas flame) is present.
Risk: Release of coolant under certain conditions could ignite and result in a fire.
Fix: Tiffin will be working with dometic in order to repair these refrigerators (Please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or tiffin at 256-356-8661.
Recall 05V-307: Electrical System
Problem: On certain motor homes containing a 50 amp transfer switch built by intellitec, the material used for the wire lugs was changed from nickel plated to copper lugs. The copper lugs are softer than the nickel plated and do not retain the torque of the screw that clamps the wire connector.
Risk: When the torque is relaxed, the lugs can become loose resulting in excessive heat within the connected wire that could result in a fire.
Fix: Dealers will replace the changeover box. The recall began on july 21, 2005. Owners may contact tiffin at 1-256-356-8661.
Recall 05V-145: Equipment
Problem: On certain recreational vehicles, the washer/dryer in the rear of the motor home can move.
Risk: A vehicle occupant could be injured if the washer/dryer moved.
Fix: Tiffin has provided the owners with a repair kit and installation instructions. The recall began on january 7, 2005. Owners may contact tiffin at 1-256-356-0205.
Recall 04V-383: Seat Belts
Problem: The seat belt assemblies on certain motor homes fail to comply with the loop load requirements of federal motor vehicle safety standard no. 209. "seat belt assemblies."
Risk: The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
Fix: Amsafe will replace the buckles. Owners should contact amsafe at 574-266-8330 or tiffin at 1-256-356-8661.
2005 Tiffin Phaeton problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Engine and Engine Cooling | 1 |
Most reported parts
- Engine and Engine Cooling › Cooling System — 1
Typical mileage at the time of the problem: 49,376 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Tiffin Phaeton complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Tiffin Phaeton years
Frequently asked questions
Does the 2005 Tiffin Phaeton have any recalls?
Yes — NHTSA lists 5 recalls for the 2005 Tiffin Phaeton: 11V-082 (equipment), 08V-509 (equipment), 05V-307 (electrical system), 05V-145 (equipment), 04V-383 (seat belts). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Tiffin Phaeton?
Owners report engine and engine cooling problems most often (1 reports). The typical mileage when problems were reported is about 49,376 miles.
Are Tiffin recall repairs free?
Yes. Safety recall repairs are free at authorized Tiffin dealers, whether you are the first owner or bought the car used.