2005 Thor California Vortex recalls and problems
The 2005 Thor California Vortex has 4 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Thor California dealer.
Recalls may cover only some 2005 Thor California Vortex vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Thor California Vortex recalls
Recall 07V-282: Latches/Locks/Linkages
Problem: On certain trailers, the lock of the side ramp door may not be properly latched by the consumer, could fail to lock properly, or the attaching hardware could come loose.
Risk: Any of these possibilities could result in the door opening upwards while in transit. The opening of this ramp door could impact nearby persons or objects resulting in personal injury or vehicle and properly damage.
Fix: Dealers will modify the set screw and install a secondary latch mechanism free of charge. The recall began on july 23, 2007. Owners should contact thor california at 888-697-8467.
Recall 06V-468: Structure
Problem: On certain cargo/travel trailers, overloading and incorrectly positioning cargo in the rear cargo area can result in alight hitch weight and affect stability.
Risk: Depending on the specific tow vehicle and its hitch equipment, a sufficiently light hitch weight can result in sway at highway speeds. Too much weight incorrectly positioned can also result in severe bending of the a-frame assembly, failure of the coupler assembly, and/or failure of the safety chains. This can cause a crash involving the trailer and tow vehicle.
Fix: Dealers will inspect the trailer, tow vehicle and hitch equipment; install new cargo load limit labels and placards in the cargo area; furnish loading limit information; replace the coupler and safety chains; and reinforce the a-frame. The recall began on november 15, 2006. Owners should contact thor at 1-888-697-8467. Note: this campaign supersedes a previous recall (Please see 04v243).
Recall 06V-466: Structure
Problem: On certain cargo/travel trailers, there is a possibility of overloading in the rear cargo area. Too much weight incorrectly positioned in this area can result in a light hitch weight and affect stability.
Risk: Depending on the specific tow vehicle and its hitch equipment, a sufficiently light hitch weight can result in sway at highway speeds. This could cause a crash involving the trailer and tow vehicle.
Fix: Owners will be asked to inspect their trailer, tow vehicle, and hitch equipment and to follow proper loading procedures as explained in the owner's guide supplement which will be provided with the owner letter. The recall began on november 15, 2006. Owners should contact thor at 1-888-697-8467. Note: this campaign supersedes a previous recall (Please see 04v242).
Recall 06V-208: Equipment
Problem: On certain travel and fifth wheel trailers equipped with suburban and atwood furnaces, the furnace exhaust vent was improperly installed. The furnace exhaust vent will allow leakage of fumes which contain combustion products, including a high concentration of potentially lethal carbon monoxide gas.
Risk: Fumes could enter into the trailer and could result in serious injury or death.
Fix: Owners will receive instructions on inspecting the furnace vent. If an owner believes the vent is installed incorrectly, is not sure how to inspect the furnace exhaust vent, or needs assistance in getting the furnace exhaust vent installation inspected and corrected, owners should contact thor immediately at 1-877-870-2638 or via the internet at http://www.thorca.com. The recall began on june 15, 2006.
2005 Thor California Vortex problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Tires | 1 |
Most reported parts
- Tires › Tread/Belt — 1
Typical mileage at the time of the problem: 3,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Thor California Vortex complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Thor California Vortex years
Compare all Thor California Vortex years · All Thor California models
Frequently asked questions
Does the 2005 Thor California Vortex have any recalls?
Yes — NHTSA lists 4 recalls for the 2005 Thor California Vortex: 07V-282 (latches/locks/linkages), 06V-468 (structure), 06V-466 (structure), 06V-208 (equipment). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Thor California Vortex?
Owners report tires problems most often (1 reports). The typical mileage when problems were reported is about 3,000 miles.
Are Thor California recall repairs free?
Yes. Safety recall repairs are free at authorized Thor California dealers, whether you are the first owner or bought the car used.