2000 Thomas ER Transit recalls and problems
The 2000 Thomas ER Transit has 7 safety recalls. Recall repairs are free at any Thomas dealer.
Recalls may cover only some 2000 Thomas ER Transit vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2000 Thomas ER Transit recalls
Recall 08V-087: Structure
Problem: Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (Additional buses have been added to this recall campaign. Please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
Risk: In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
Fix: Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336-889-4871.
Recall 02V-221: Wheels
Problem: On certain school and transit buses, the wheel lug nut may not tighten completely.
Risk: The wheel could loosen increasing the risk of loss of control of the vehicle.
Fix: Dealers will install new wheel studs. Owner notification began february 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.
Recall 01V-105: Service Brakes, Air
Problem: Vehicle description: certain school buses fail to comply with requirements of FMVSS no. 121, "air brake systems." these vehicles do not comply due to the low air warning system detecting pressure in only one reservoir system and not both as required.
Risk: This does not meet the standard.
Fix: Dealers will correct the low air pressure switch wiring. Owner notification began july 27, 2001. Owner notification is expected to begin owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-881-7219.
Recall 00V-362: Seats
Problem: Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. A bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. This bracket is located at the top of the height adjuster.
Risk: If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
Fix: Dealers will replace the seat base and add reinforcement to the seat assembly
Recall 00V-232: Service Brakes, Air
Problem: Vehicle description: school bus chassis and emergency vehicles built with bendix air ABS with an ec-17 1030r electronic control unit (Ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
Risk: This condition could cause the ABS ECU to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
Fix: Dealers will replace the ABS ECU.
Recall 00V-232: Service Brakes, Air
Problem: Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an ec-17 1030r electronic control unit (Ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
Risk: This condition could cause the ABS ECU to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
Fix: Dealers will replace the ABS ECU.
Recall 00V-174: Exterior Lighting
Problem: Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. The higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.
Risk: This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.
Fix: Dealers will install a relay to reduce the current draw through the headlight switch. Owner notification began september 8, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.
Other Thomas ER Transit years
Frequently asked questions
Does the 2000 Thomas ER Transit have any recalls?
Yes — NHTSA lists 7 recalls for the 2000 Thomas ER Transit: 08V-087 (structure), 02V-221 (wheels), 01V-105 (service brakes, air), 00V-362 (seats), 00V-232 (service brakes, air) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are Thomas recall repairs free?
Yes. Safety recall repairs are free at authorized Thomas dealers, whether you are the first owner or bought the car used.