2018 Thomas Built Buses SAF-T-Liner EFX recalls and problems
The 2018 Thomas Built Buses SAF-T-Liner EFX has 14 safety recalls. Recall repairs are free at any Thomas Built Buses dealer.
Recalls may cover only some 2018 Thomas Built Buses SAF-T-Liner EFX vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2018 Thomas Built Buses SAF-T-Liner EFX recalls
Recall 22V-762: Structure
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Risk: A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Fix: Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.
Recall 22V-510: Seats
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.
Risk: Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.
Fix: Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.
Recall 19V-712: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2020 Thomas Built Saf-T-Liner EFX, Minotour, Saf-T-Liner C2, and Saf-T-Liner HDX school buses equipped with SynTec S3B or S3C seats. The seats may have been manufactured with styrene blocks that may not provide sufficient impact absorption in certain specific areas around the steel seat frame of the back support. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection."
Risk: The lack of impact absorption increases the risk of injury in the event of a crash.
Fix: DTNA will notify owners, and dealers will install additional impact material between the re-bond back and the vinyl back cover to increase the amount of absorption, free of charge. DTNA issued owners an interim notification on November 29, 2019. The recall began June 22, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-832.
Recall 19V-444: Service Brakes, Air
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2010-2020 Thomas Built Buses Saf-T-Liner C2, 2016-2019 HDX, and 2017-2019 EFX school buses equipped with Bendix Air Disc Brakes. The driver side rear brakes may drag.
Risk: The dragging brakes may lead to high temperatures at the wheel end, increasing the risk of smoke and fire, possibly resulting in the bus having to be evacuated, which can increase the risk of injury.
Fix: DTNA will notify owners, and dealers will install a new caliper with an updated clearance adjustment mechanism, free of charge. The recall began August 9, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-818.
Recall 18V-914: Suspension, Steering
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2018-2019 Thomas Built Saf-T-Liner HDX, C2, and EFX School Buses, equipped with Detroit Axle axles. The affected vehicles may have loose steering tie rod arm bolts.
Risk: Loose tie rod arm bolts may lead to separation of the tie rod arm, affecting vehicle steering, and increasing the risk of a crash.
Fix: DTNA has notified owners, and dealers will inspect the steering arm and tie rod arm bolts for to make sure that they are properly tightened, installing new fasteners as necessary, free of charge. The recall began February 9, 2019. Owners may contact Daimler Trucks at 1-800-547-0712. DTNA's number for this recall is FL-802.
Recall 18V-702: Service Brakes, Air
Problem: Daimler Trucks North America, LLC (DTNA) is recalling certain 2018-2019 Thomas Built school buses Saf-T-Liner C2, Saf-T-Liner HDX and Saf-T-Liner EFX school buses. The brake caliper mounting bolts may have been insufficiently tightened.
Risk: Loose brake caliper mounting bolts can reduce brake effectiveness, increasing the risk of a crash.
Fix: DTNA has notified owners, and dealers will check and tighten the brake caliper mounting bolts, free of charge. The recall began December 3, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-794.
Recall 18V-409: Service Brakes, Air
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2018 Thomas Built Buses Saf-T-Liner EFX school buses. The check valve for the air brake system may not be plumbed correctly which can cause the primary air system to not be isolated from the secondary air system.
Risk: In the event of a rapid loss of air pressure in the secondary system, the incorrectly plumbed check valve can cause rapid air loss in both secondary and primary system, causing the parking brakes to activate suddenly. This will increase the risk of a crash.
Fix: DTNA will notify owners, and dealers will inspect and repair the check valve as needed, free of charge. The recall began on August 12, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-774.
Recall 18V-410: Service Brakes, Air
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2018 Thomas Built Buses Saf-T-Liner EFX transit buses. The check valve for the air brake system may not be plumbed correctly which can cause the primary air system to not be isolated from the secondary air system.
Risk: In the event of a rapid loss of air pressure in the secondary system, the incorrectly plumbed check valve can cause rapid air loss in both secondary and primary system, causing the parking brakes to activate suddenly. This will increase the risk of a crash.
Fix: DTNA will notify owners, and dealers will inspect and repair the check valve as needed, free of charge. The recall began on August 12, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-774.
Recall 18V-352: Service Brakes, Hydraulic
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner EFX and Saf-T-Liner HDX school buses equipped with air disc brakes. The brake caliper mounting bolts on these vehicles may be insufficiently tightened, allowing the bolts to loosen.
Risk: If the brake caliper mounting bolts come loose, braking performance may be reduced, increasing the risk of a crash.
Fix: DTNA will notify owners, and dealers will inspect the brake caliper mounting bolts and tighten them as necessary, free of charge. DTNA issued owners an interim notification on July 25, 2018. The recall began September 4, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-772.
Recall 18V-253: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2018 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, Saf-T-Liner EFX, and Minotour school buses equipped with S3B Restraint Wall Mounted Seats. The wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash.
Risk: In the event of a crash, if the seat does not remain secured to the wall, the occupant has an increased risk of an injury.
Fix: DTNA will notify owners, and dealers will install an additional wall mounting bracket, free of charge. Daimler issued owners an interim notification on June 12, 2018. The recall began January 3, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-769.
Recall 18V-254: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2018 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour transit buses, equipped with certain S3B Restraint Wall Mounted Seats. The wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash.
Risk: In the event of a crash, if the seat does not remain secured to the wall, the occupant has an increased risk of an injury.
Fix: DTNA will notify owners, and dealers will install an additional wall mounting bracket, free of charge. Daimler issued an interim notification to owners on June 15, 20 18. The recall began January 3, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-769.
Recall 18V-192: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2018 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, Saf-T-Liner EFX, and Minotour school buses, equipped with certain Syntec-brand S3B, Non-Restraint, Wall Mounted Seats. The wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash.
Risk: In the event of a crash, if the seat does not remain secured to the wall, the occupant has an increased risk of an injury.
Fix: DTNA will notify owners, and dealers will install an additional wall mounting bracket, free of charge. DTNA issued an interim notification to owners on May 9, 2018. The recall began May 10, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-763.
Recall 18V-193: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2018 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, Saf-T-Liner EFX, and Minotour transit buses, equipped with certain Syntec-brand S3B, Non-Restraint, Wall Mounted Seats. The wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash.
Risk: In the event of a crash, if the seat does not remain secured to the wall, the occupant has an increased risk of an injury.
Fix: DTNA will notify owners, and dealers will install an additional wall mounting bracket, free of charge. DTNA issued an interim notification to owners on May 10, 2018. The recall began May 10, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-763.
Recall 17V-313: Seats
Problem: Daimler Trucks North America LLC (DTNA) is recalling certain 2014-2018 Thomas Built Buses Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The occupant seats may have been installed without under-rail washers, reducing their anchorage strength.
Risk: Without under-rail washers, in the event of a crash, the seats may come loose, increasing the risk of injury.
Fix: DTNA will notify owners, and dealers will inspect the seats and replace the mounting hardware, as necessary, free of charge. The recall began on June 28, 2017. Owners may contact DTNA Customer Service 1-800-547-0712. DTNA's number for the recall is FL-737.
Other Thomas Built Buses SAF-T-Liner EFX years
Compare all Thomas Built Buses SAF-T-Liner EFX years · All Thomas Built Buses models
Frequently asked questions
Does the 2018 Thomas Built Buses SAF-T-Liner EFX have any recalls?
Yes — NHTSA lists 14 recalls for the 2018 Thomas Built Buses SAF-T-Liner EFX: 22V-762 (structure), 22V-510 (seats), 19V-712 (seats), 19V-444 (service brakes, air), 18V-914 (suspension, steering) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are Thomas Built Buses recall repairs free?
Yes. Safety recall repairs are free at authorized Thomas Built Buses dealers, whether you are the first owner or bought the car used.