2007 Sterling L-Line recalls and problems
The 2007 Sterling L-Line has 8 safety recalls and 3 owner complaints filed with NHTSA. Recall repairs are free at any Sterling dealer.
Recalls may cover only some 2007 Sterling L-Line vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2007 Sterling L-Line recalls
Recall 11V-478: Fuel System, Diesel
Problem: Daimler trucks is recalling certain model year 2004 through 2008 heavy trucks manufactured from july 11, 2003, through september 28, 2007, equipped with epa04 model mbe4000 engines built with plastic low pressure fuel lines and fuel filters mounted near the center of the engine on the left-hand side. The plastic low pressure fuel line between engine mounted fuel filter and engine block may develop a substantial diesel fuel leak.
Risk: This could create a road hazard increasing the risk of a crash. Fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities. Vehicles will be inspected and the plastic low pressure fuel line will be replaced with a steel low pressure fuel line. This service will be performed free of charge. An interim letter was mailed to owners on october 28, 2011. The safety recall began on february 21, 2012. Owners may contact daimler trucks at 1-800-547-0712.
Recall 11V-136: Fuel System, Other
Problem: Daimler trucks is recalling certain model year 2005-2007 sterling l-line vehicles configured with car hauler bodies and chassis, and equipped with epa04 mbe4000 engines with a fuel filter mounted at the rear of the engine, manufactured from september 13, 2004, through october 10, 2007. The lower low pressure fuel lines between the primary fuel pump and the engine mounted fuel filter, and the upper low pressure fuel line between the engine mounted fuel filter and the engine block may develop a substantial diesel fuel leak from cracking, or from abrasion due to contact with other components.
Risk: Fuel leak onto the roadway could cause a slippery road surface that could result in a crash.
Fix: Dealers will replace the upper and lower low pressure fuel lines with a more robust fuel lines. This service will be performed free of charge. Dtna will notify owners of the recall during april 2011. The safety recall began on november 1, 2011. Owners may contact daimler trucks at 1-800-547-0712.
Recall 09V-366: Engine and Engine Cooling
Problem: Daimler trucks is recalling model year 2004-2010 trucks equipped with caterpillar c15 engine. The variable valve actuation oil line may rub against the p-clips retaining the oil line, causing an oil leak.
Risk: An oil leak may result in a fire.
Fix: Daimler trucks is working with caterpillar to remedy these vehicles. Please see caterpillar's defect report 09e-020. Caterpillar will inspect and repair the necessary components free of charge. The recall began on may 5, 2009. Owners may contact caterpillar toll-free at 1-800-447-4986 or daimler trucks at 1-800-547-0712.
Recall 08V-113: Fuel System, Diesel
Problem: Daimler trucks is recalling 62,000 my 2005-2007 freightliner business class, century class, columbia, coronado, fld, classic, sterling a-line, l-line, and western star 4900 trucks. A fractured fuel line could leak diesel fuel.
Risk: If a leak continues undetected under certain conditions, fuel may ignite at a hot engine surface and/or fuel may be spilled on the road surface.
Fix: High pressure fuel lines and transfer tubes will be inspected and replaced free of charged. The recall began on july 9, 2008. Owners may contact daimler trucks at 1-800-547-0712.
Recall 07V-530: Trailer Hitches
Problem: On certain truck-tractors equipped with holland simplex se or se II fifth wheels, the latch lever pivot bolt assembly may have been over-tightened which could distort the pivot bolt spacer sleeve. Corrosion or contaminates in the pivot may cause it to bind and prevent the fifth wheel jaw from latching securely around the trailer king pin.
Risk: There is a possibility that the fifth wheel may fail to latch without the driver's knowledge. When the occurs, the driver could drive away and the trailer could become disengaged increasing the risk of a crash.
Fix: Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer. The recall began on january 3, 2008. Owners may contact freightliner at 1-800-547-0712.
Recall 07V-333: Wheels
Problem: On certain trucks built with axilok rear wheel spindle nuts, the nuts may have been improperly installed, with one or both locking clip tabs not properly engaged or damaged.
Risk: This may reduce the nut's ability to resist rotation, potentially allowing the nut to back off and the dual wheel set to separate from the vehicle, resulting in a crash without prior warning.
Fix: Dealers will inspect the axilok nuts for locking clip engagement or damage. They will be adjusted or replaced free of charge. The recall began on august 10, 2007. Owners may contact freightliner at 800-547-0712.
Recall 07V-306: Steering
Problem: Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (Aac) front axles. During the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
Risk: Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
Fix: Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. The recall began on december 21, 2007. Owners can contact freightliner at 1-800-547-0712.
Recall 07V-302: Service Brakes, Air
Problem: Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between july 2002 and july 3, 2007, equipped with bendix sr-7 spring brake control valves. The parker scv brass 90 degree single check valves (Scv) which attach to the supply port of a bendix sr-7 spring brake modulating valve can break apart. Pieces of the parker scv can become lodged inside the sr-7 spring brake modulating valve, potentially causing either leakage out of the sr-7 valve or preventing air from properly exhausting from the sr-7 valve. Also, due to a manufacturing defect in the internal rubber check valve inside the sr-7 spring brake modulating valves, the valves can become deformed and not seat properly.
Risk: These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.
Fix: Freightliner will notify owners and repair the vehicles free of charge. The recall began on january 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on february 1, 2008. Owners can contact freightliner at 1-800-547-0712.
2007 Sterling L-Line problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Fuel System, Diesel | 2 | |
| Steering | 1 | |
| Tires | 1 |
Typical mileage at the time of the problem: 219,212 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2007 Sterling L-Line complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Sterling L-Line years
Frequently asked questions
Does the 2007 Sterling L-Line have any recalls?
Yes — NHTSA lists 8 recalls for the 2007 Sterling L-Line: 11V-478 (fuel system, diesel), 11V-136 (fuel system, other), 09V-366 (engine and engine cooling), 08V-113 (fuel system, diesel), 07V-530 (trailer hitches) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2007 Sterling L-Line?
Owners report fuel system, diesel problems most often (2 reports), followed by steering (1). The typical mileage when problems were reported is about 219,212 miles.
Are Sterling recall repairs free?
Yes. Safety recall repairs are free at authorized Sterling dealers, whether you are the first owner or bought the car used.