2004 Pontiac Aztek recalls and problems

The 2004 Pontiac Aztek has 3 safety recalls and 67 owner complaints filed with NHTSA. Recall repairs are free at any Pontiac dealer.

Recalls
3
Complaints
67
Crashes / fires
5 / 0
Injuries / deaths
6 / 0

Recalls may cover only some 2004 Pontiac Aztek vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 Pontiac Aztek recalls

Recall 07V-349: Fuel System, Gasoline

Reported Aug 8, 2007 · 20,594 vehicles affected · GENERAL MOTORS CORP.

Problem: On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (Icv).

Risk: A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. Fuel leakage, in the presence of an ignition source, could result in a fire.

Fix: Dealers will replace the fuel tank. The recall will be mailed in two phases with the first phase beginning on december 4, 2007. The second phase will be mailed on december 13, 2007. Owners may contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; or pontiac at 1-800-620-7668. The vehicle population includes buick rendezvous and pontiac aztek vehicle built in may 2003; chevrolet venture and pontiac montana vehicles built from june through august 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.

Recall 05V-157: Electrical System

Reported Apr 20, 2005 · 34,186 vehicles affected · GENERAL MOTORS CORP.

Problem: On certain sport utility vehicles, contamination on ignition relay contacts can cause high resistance. This can affect signals to the powertrain control module and, could cause intermittent vehicle stalls at any time.

Risk: The vehicle cannot be restarted immediately. If this were to occur, it could result in a vehicle crash.

Fix: Dealers will replace the ignition relay free of charge. The recall began on may 4, 2005. Owners may contact pontiac at 1-800-620-7668 and buick at 1-866-608-8080.

Recall 03V-454: Fuel System, Gasoline

Reported Nov 10, 2003 · 79 vehicles affected · GENERAL MOTORS CORP.

Problem: On certain passenger vehicles, a weld between the fuel tank inlet check valve and the fuel tank can fail.

Risk: If these parts separate, the driver may notice an odor of fuel, the service engine soon or check engine light may illuminate, and/or fuel may leak onto the ground. Fuel leakage in the presence of an ignition source could result in a fire.

Fix: Dealers will inspect the serial number of the fuel tank to see if it is on the list of affected tanks. If the serial number matches, the fuel tank will be replaced. Owner notification began november 4, 2003. Owners should contact buick at 1-866-608-8080 or pontiac at 1-800-620-7668.

2004 Pontiac Aztek problems reported by owners

Problem areaReports
Electrical System15
Service Brakes, Hydraulic10
Engine and Engine Cooling8
Suspension8
Fuel/Propulsion System8
Fuel System, Gasoline7
Air Bags5
Engine5
Power Train4
Visibility3
Steering3
Vehicle Speed Control3

Most reported parts

  • Suspension › Front › Wheel Bearing — 8
  • Engine and Engine Cooling › Engine — 5
  • Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 5
  • Electrical System › Ignition — 4
  • Steering › Hydraulic Power Assist System — 2
  • Fuel System, Gasoline › Storage — 2
  • Tires › Pressure Monitoring and Regulating Systems — 1
  • Structure › Frame and Members — 1

Typical mileage at the time of the problem: 48,146 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 Pontiac Aztek complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine · reported Apr 29, 2020
I have been smelling gas from my car for years but just never had the money to get it looked at. I even called about recalls concerning the fuel system that I found out about through research in 2015 but was told they had been closed so I would be charged for the repairs even if it was previously covered under recall. I no longer fill my tank with gas because there is a leak. I just got my car back from the dealership, they state that I need a new fuel tank, and fuel lever sensor and sender. Also, have oil leaks in 2 places, they tell me I need upper & lower intake gaskets. As well as valve…
Unknown or Other · at 117,000 miles · reported Apr 1, 2020
Fuel tank is leaking; there is a history of a recall that has never been repaired on this vehicle. It is a safety issue.
Seats · at 171,000 miles · reported Mar 27, 2020
The contact owns a 2004 pontiac aztec. The contact stated that while driving 20 MPH crashed into a gmc envoy and flipped over landing on the roof. The contact stated that the air bags failed to deploy. There were no warning lights illuminated prior to the failure. A police report was filed. The seat belt failed to unlock as the contact was cut from the vehicle. The contact struck the steering wheel, was unconscious, and sustained injuries to the eye which required medical attention. The vehicle was towed to an independent lot. The occupant of the gmc had no reported injuries. The local dealer…
Service Brakes · at 95,000 miles · reported Jan 17, 2019
The contact owns a 2004 pontiac aztek. While driving 35 MPH, the contact attempted to stop the vehicle and the brake pedal traveled to the floorboard. The vehicle finally stopped before reaching an intersection. The contact noticed that brake fluid was leaking and the brake hoses were fractured. There were no warning indicators illuminated. The vehicle was taken to a local mechanic who diagnosed that the brake system was fractured. The brakes and hoses were repaired. The manufacturer was notified and did not assist. The dealer was not notified. The failure mileage was 95,000.. Consumer stated…
Electrical System · at 10 miles · reported Jul 1, 2018
My car turn off on my children and I on the highway thank god we was able to coast on the side of the road. My mechanic said that my ignition control module went out outta no where not only that crankshaft sensor and fuel line exhausted system something wrong engine light still on. With that being said I'm great my children was not hurt doing this ordeal. I learned that these cars have few complaints. But do have some issues with electrical system and vacuum how's exhausted. Just got the car I march and found out bout this recall I'm so disappointed scared to drive this car right now.

Other Pontiac Aztek years

Compare all Pontiac Aztek years · All Pontiac models

Frequently asked questions

Does the 2004 Pontiac Aztek have any recalls?

Yes — NHTSA lists 3 recalls for the 2004 Pontiac Aztek: 07V-349 (fuel system, gasoline), 05V-157 (electrical system), 03V-454 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 Pontiac Aztek?

Owners report electrical system problems most often (15 reports), followed by service brakes, hydraulic (10). The typical mileage when problems were reported is about 48,146 miles.

Are Pontiac recall repairs free?

Yes. Safety recall repairs are free at authorized Pontiac dealers, whether you are the first owner or bought the car used.