2006 Nissan Titan recalls and problems
The 2006 Nissan Titan has 5 safety recalls and 430 owner complaints filed with NHTSA. Recall repairs are free at any Nissan dealer.
Recalls may cover only some 2006 Nissan Titan vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2006 Nissan Titan recalls
Recall 10V-517: Engine and Engine Cooling
Problem: Nissan is recalling certain model year 2004-2006 armada, titan, infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. The intelligent power distribution module (Ipdm) assembly contains an engine control module (Ecm) relay that has a diode for electrical current noise reduction. The ECM relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ECM relay contact due to arcing.
Risk: This could cause engine stalling increasing the risk of a crash.
Fix: Dealers will replace the ECM relay inside the ipdm assembly. This service will be performed free of charge. The safety recall began on december 6, 2010. Owners may contact nissan at 1-800-647-7261.
Recall 10V-074: Fuel System, Other
Problem: Nissan is recalling certain model year 2005-2009 titan, armada, and infiniti qx56 vehicles. The instrument panel fuel gauge may inaccurately display that the vehicle still has some fuel, typically about one quarter tank, when the fuel tank is empty.
Risk: This could cause the vehicle to run out of gas and stall on the highway, which could cause a crash.
Fix: Dealers will replace the fuel sender unit inside the fuel tank with a new improved sender card. This service will be performed free of charge. The safety recall began on march 22, 2010. Owners may contact nissan at 1-800-647-7261.
Recall 08V-284: Equipment
Problem: Nissan is recalling 180,664 my 2005-2006 titan, armada and infinity qx56 vehicles manufactured after march 17, 2005, that are equipped with a visteon air conditioning condenser fan motor. The fan motor may not be properly sealed allowing excessive water intrusion and inadequate drainage of moisture.
Risk: This could cause corrosion in the motor leading possibly to overheating and a fire.
Fix: Dealers will install a 'thermal protector kit' and test the air conditioning condenser fan motor and replace it if necessary. The recall began on august 2, 2008. Owners may contact nissan at 1-800-647-7261.
Recall 06V-459: Electrical System
Problem: On certain king cab trucks, the wires in the harness were routed through the rear doors and into the body. These wires may break due to over bending of the harness as the door is opened and closed. The harness contains wires for the driver seat belt pretensioner and for the front passenger seat belt which is part of the occupant classification system. Wires for the rear audio speakers are also contained n the harness.
Risk: If the wires for the seat belts and speaker wires break and make contact, there is a possibility that the pretensioner may deploy. If this happens when the seat belt is retracted, it will not be possible to use the seat belt. If one of the wires on the right side harness for the seat belt tension sensor breaks, the passenger side front air bag will not deploy as designed in a frontal collision increasing the risk of a crash and personal injury.
Fix: Dealers will replace the wire harness cover with a different type that prevents over bending of the harness and the harness will be rerouted free of charge. The recall began on february 19, 2007. Owners may contact nissan at 1-800-647-7261.
Recall 06V-064: Latches/Locks/Linkages
Problem: Certain light trucks fail to comply with the requirements of federal motor vehicle safety standard no. 206, "door locks and door retention components." an arc weld is missing on some right side rear door upper latch assemblies.
Risk: This may result in the right side doors coming partially open increasing the risk of injury to occupants.
Fix: Dealers will replace the upper latch assembly free of charge. The recall began on april 3, 2006. Owners may contact nissan at 800-662-6200.
2006 Nissan Titan problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Power Train | 198 | |
| Electrical System | 46 | |
| Suspension | 45 | |
| Engine | 39 | |
| Engine and Engine Cooling | 36 | |
| Service Brakes, Hydraulic | 29 | |
| Air Bags | 28 | |
| Service Brakes | 16 | |
| Unknown or Other | 12 | |
| Fuel System, Gasoline | 12 | |
| Tires | 11 | |
| Visibility | 8 |
Most reported parts
- Power Train › Driveline — 50
- Suspension › Rear — 20
- Power Train › Driveline › Differential Unit — 17
- Power Train › Axle Assembly › Axle Shaft › Seal — 16
- Engine and Engine Cooling › Exhaust System — 7
- Power Train › Automatic Transmission — 5
- Power Train › Axle Assembly — 4
- Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 4
Typical mileage at the time of the problem: 63,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Nissan Titan complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Nissan Titan years
Frequently asked questions
Does the 2006 Nissan Titan have any recalls?
Yes — NHTSA lists 5 recalls for the 2006 Nissan Titan: 10V-517 (engine and engine cooling), 10V-074 (fuel system, other), 08V-284 (equipment), 06V-459 (electrical system), 06V-064 (latches/locks/linkages). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2006 Nissan Titan?
Owners report power train problems most often (198 reports), followed by electrical system (46). The typical mileage when problems were reported is about 63,000 miles.
Are Nissan recall repairs free?
Yes. Safety recall repairs are free at authorized Nissan dealers, whether you are the first owner or bought the car used.