2001 New Flyer D60HF recalls and problems
The 2001 New Flyer D60HF has 4 safety recalls. Recall repairs are free at any New Flyer dealer.
Recalls may cover only some 2001 New Flyer D60HF vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2001 New Flyer D60HF recalls
Recall 08V-053: Equipment
Problem: New flyer is recalling 431 my 1996-2001 d60hf diesel transit buses equipped with a rooftop air conditioning evaporator. The evaporator drain lines make contact with components (Ballast assemblies) within the interior lighting panel below the drain line port. This can result in either damage to the drain line, which introduces moisture into the lighting panel, or restriction of the line which results in a back-up and overflow of moisture through the fresh air return vent and back into the lighting panel.
Risk: Moisture in sufficient quantities within the lighting panel may result in a shorting of the electrical components and a vehicle fire.
Fix: New flyer will incorporate an elbow fitting into the drain line where it enters the lighting panel from the roof, which will promote clearance between the line and the ballast assembly. The recall began on february 6, 2008. Owners may contact new flyer at 1-204-934-4803.
Recall 07V-268: Steering
Problem: On certain transit buses, the u-joint assemblies have inadequate spline engagement on one of the two end yokes.
Risk: Excessive play in the steering system could develop and, if not corrected, cause a loss of steering control which could result in a crash.
Fix: The u-joint assembly will be inspected and replaced if necessary. The recall began on june 10, 2007. Owners may contact new flyer at 1-204-934-4874.
Recall 04V-042: Wheels
Problem: On certain transit buses, the center axle wheel end brakes may not release after being parked for an extended period of time.
Risk: The driver could lose control of the vehicle when driving away from a parked position, which could result in a crash.
Fix: New flyer will install an additional air system r14 relay valve, #4 notch automatic slack adjusters, and type 30 long stoke brake chambers on the center axle; the logic control module will be reprogrammed, add new ABS components (Sensors, speed rings and harnesses) if not already equipped with ABS; and will revise plc programming. Owners may contact new flyer at 1-204-982-8400.
Recall 03V-248: Service Brakes, Air
Problem: Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." the service brake release timing and park brake apply timing are out of compliance with the standard.
Risk: These vehicles do not comply with federal standards.
Fix: To resolve the issue of noncompliance with the service brake release timing, dealers will re-route the redundant signal line to the center axle relay valve and the center and rear relay valves will be swapped. Owner notification began july 17, 2003. Owners should contact new flyer at 1-204-982-8400.
Other New Flyer D60HF years
Frequently asked questions
Does the 2001 New Flyer D60HF have any recalls?
Yes — NHTSA lists 4 recalls for the 2001 New Flyer D60HF: 08V-053 (equipment), 07V-268 (steering), 04V-042 (wheels), 03V-248 (service brakes, air). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are New Flyer recall repairs free?
Yes. Safety recall repairs are free at authorized New Flyer dealers, whether you are the first owner or bought the car used.