2001 New Flyer D35LF recalls and problems
The 2001 New Flyer D35LF has 4 safety recalls. Recall repairs are free at any New Flyer dealer.
Recalls may cover only some 2001 New Flyer D35LF vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2001 New Flyer D35LF recalls
Recall 07V-068: Exterior Lighting
Problem: Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.
Risk: The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Fix: Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (Plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204-934-4874.
Recall 02V-112: Steering
Problem: On certain low floor buses, the power steering hose was incorrectly installed.
Risk: The hose can leak, creating the risk of an engine fire.
Fix: Dealers will replace the hose. Owner notification began july 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-228-8984.
Recall 02V-004: Vehicle Speed Control
Problem: On certain buses equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
Risk: If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
Fix: Williams controls is handling the replacement of this pedal. Owners who do not receive the free remedy within a reasonable time should contact williams control at 1-503-684-8600 or new flyer at 204-982-8181.
Recall 01V-265: Steering
Problem: Vehicle description: transit buses. The clamp nuts for the center link tie rods may have been inadequately tightened.
Risk: Inadequately tightened clamp nuts could lead to the tie rods separating from the center link possibly resulting in a vehicle crash.
Fix: New flyer will will inspect the tie rod end clamp lock nuts to ensure that the nuts are properly tightened. Any damaged tie rods will be replaced. Owner notification began september 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-982-8181.
Other New Flyer D35LF years
Frequently asked questions
Does the 2001 New Flyer D35LF have any recalls?
Yes — NHTSA lists 4 recalls for the 2001 New Flyer D35LF: 07V-068 (exterior lighting), 02V-112 (steering), 02V-004 (vehicle speed control), 01V-265 (steering). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are New Flyer recall repairs free?
Yes. Safety recall repairs are free at authorized New Flyer dealers, whether you are the first owner or bought the car used.