Home › Jeep › Wrangler › 2000

2000 Jeep Wrangler recalls and problems

The 2000 Jeep Wrangler has 1 safety recall and 251 owner complaints filed with NHTSA. Recall repairs are free at any Jeep dealer.

Recalls
1
Complaints
251
Crashes / fires
17 / 20
Injuries / deaths
11 / 0

Recalls may cover only some 2000 Jeep Wrangler vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2000 Jeep Wrangler recalls

Recall 02V-104: Fuel System, Gasoline

Reported Apr 8, 2002 · 1,115,322 vehicles affected · DAIMLERCHRYSLER CORPORATION

Problem: On certain sport utility vehicles equipped with a 4.0l engine only, the design of the intake and exhaust manifolds could allow debris to accumulate at the #3 cylinder location.

Risk: This could result in a vehicle fire.

Fix: Dealers will install a manifold shield to modify the air flow characteristics and to prevent the accumulation of debris in the area of the #3 cylinder. Owner notification began may 13, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2000 Jeep Wrangler problems reported by owners

Problem areaReports
Power Train75
Structure56
Suspension25
Electrical System24
Engine and Engine Cooling19
Air Bags16
Seat Belts15
Service Brakes, Hydraulic13
Steering11
Unknown or Other9
Engine9
Fuel System, Gasoline7

Most reported parts

  • Power Train › Manual Transmission — 50
  • Structure › Body — 27
  • Structure › Frame and Members — 12
  • Power Train › Automatic Transmission — 11
  • Structure › Frame and Members › Underbody Shields — 11
  • Engine and Engine Cooling › Engine › Gasoline — 9
  • Air Bags › Frontal — 7
  • Seat Belts › Front › Anchorage — 4

Typical mileage at the time of the problem: 91,912 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2000 Jeep Wrangler complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Parking Brake · at 262,384 miles · reported Mar 13, 2026
The contact owns a 1994 N/A Jeep Wrangler. The contact stated that the vehicle failed the State Inspection because the VIN was included in NHTSA Campaign Number: 02V041000 (PARKING BRAKE). However, the part to do the recall repair was no longer available. The contact had not experienced a failure. The vehicle was not repaired. The manufacturer was notified of the issue. The mileage at the failure of the State Inspection was 262,384.
Fuel System, Gasoline · at 172,000 miles · reported Feb 5, 2026
The contact owns a 1993 N/A Jeep Wrangler. The contact stated that there was a strong fuel odor coming from the vehicle after the vehicle was refueled. Additionally, the contact stated that the vehicle was experiencing rough idling and reduced power while driving. The vehicle was taken to the dealer, where the contact was informed that the VIN was included in NHTSA Campaign Number: 94V106000 (Fuel System, Gasoline); however, the dealer later informed the contact that the recall part had been discontinued. The vehicle was not repaired. The manufacturer was contacted and confirmed that the…
Suspension · at 147,900 miles · reported May 3, 2021
We have found that after removing the bolts from the cross member under the jeep that the holes are rusted out. In fact the frame on both sides of our jeep are rusted through from not having any drain holes for the water to drain out.
Structure · at 200,000 miles · reported Aug 13, 2020
Frame rotted from the inside out around the lower control arms. The chassis is otherwise rust free, but it spontaneously rotted from the inside out. The lower control arm disconnected while driving down the highway, leaving the rear axle free floating, unstable, and very likely to cause a crash. The frame has holes in it that let water in. There is no drainage hole where the frame goes from flat on the bottom and curves up around the wheel wells. Water gets into the frame, sits there, and rots it from the inside out. There is no way to see this rot from the outside and there is no way to fix…
Structure · at 150,000 miles · reported Aug 13, 2020
The front frame cap, or mounting bracket has started is rotting and deteriorating. This is a major concern which has courses many other severe issues. This is a major suspension component that is rotting away.

Other Jeep Wrangler years

202620252024202320222021202020192018201720162015201420132012201120102009200820072006200520042003200220012000

Compare all Jeep Wrangler years · All Jeep models

Frequently asked questions

Does the 2000 Jeep Wrangler have any recalls?

Yes — NHTSA lists 1 recall for the 2000 Jeep Wrangler: 02V-104 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2000 Jeep Wrangler?

Owners report power train problems most often (75 reports), followed by structure (56). The typical mileage when problems were reported is about 91,912 miles.

Are Jeep recall repairs free?

Yes. Safety recall repairs are free at authorized Jeep dealers, whether you are the first owner or bought the car used.