2004 Itasca Sunova recalls and problems
The 2004 Itasca Sunova has 6 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Itasca dealer.
Recalls may cover only some 2004 Itasca Sunova vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2004 Itasca Sunova recalls
Recall 10V-525: Equipment
Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Recall 04V-609: Fuel System, Gasoline
Problem: On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
Risk: Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.
Recall 04V-608: Seat Belts
Problem: Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Risk: The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
Fix: Dealers will replace the buckles. The recall began on november 12, 2004. Owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.
Recall 04V-358: Equipment
Problem: On certain motor homes equipped with samsung microwave ovens, models mr1031wb, mr1032bb, mr1033sb, mr1351wb, and mr1352bb, the microwaves were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
Risk: An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
Fix: Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 1-800-932-3837 or winnebago at 1-641-585-3535.
Recall 03V-405: Equipment
Problem: On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
Risk: An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
Fix: Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535.
Recall 03V-243: Equipment
Problem: On certain motor homes, when the cooking range and furnace are operating at the same time, the flame on the cooking range could be forced downward over the burner or flame outage could occur. This condition is due to the location of the furnace and cooking range whereby the furnace may draw air in from above the range burners and cause a downdraft.
Risk: Should this occur, the flame may go out, and the liquid propane (Lp) gas will continue to flow. This is a hazardous situation that could result in an explosion or fire.
Fix: Dealers will install an air restrictor panel under the range. Owner notification began july 10, 2003. Owners should contact winnebago at 1-641-585-6939.
2004 Itasca Sunova problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Service Brakes, Hydraulic | 1 |
Most reported parts
- Service Brakes, Hydraulic › Foundation Components › Disc › Caliper — 1
Typical mileage at the time of the problem: 22,635 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2004 Itasca Sunova complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Itasca Sunova years
Frequently asked questions
Does the 2004 Itasca Sunova have any recalls?
Yes — NHTSA lists 6 recalls for the 2004 Itasca Sunova: 10V-525 (equipment), 04V-609 (fuel system, gasoline), 04V-608 (seat belts), 04V-358 (equipment), 03V-405 (equipment) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2004 Itasca Sunova?
Owners report service brakes, hydraulic problems most often (1 reports). The typical mileage when problems were reported is about 22,635 miles.
Are Itasca recall repairs free?
Yes. Safety recall repairs are free at authorized Itasca dealers, whether you are the first owner or bought the car used.