2005 Itasca Sundancer recalls and problems
The 2005 Itasca Sundancer has 4 safety recalls and 1 owner complaint filed with NHTSA. Recall repairs are free at any Itasca dealer.
Recalls may cover only some 2005 Itasca Sundancer vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2005 Itasca Sundancer recalls
Recall 06V-456: Equipment
Problem: On certain motor homes equipped with front overhead televisions, incorrect fasteners were used to secure the television located in the front overhead area of the motor home.
Risk: The television may become loose and possibly fall from its position which has the potential to impact the driver or passengers, resulting in personal injury and/or vehicle and property damage.
Fix: Dealers will inspect the vehicle to assure the correct fasteners (Bolts) were used in the tv retention strap. The recall began on december 15, 2006. Owners may contact winnebago at 1-800-537-1885.
Recall 05V-475: Fuel System, Gasoline
Problem: On certain motor homes built on ford chassis, the fasteners holding the fuel tank mounting straps may not have been properly tightened, allowing the possibility for the fuel tank to loosen and fall.
Risk: If the fuel tank falls, there is the potential for the tank to ignite, resulting in personal injury, vehicle and property damage.
Fix: Dealers will inspect and properly tighten the fasteners to the fuel tank straps. The recall began on october 15, 2005. Owners may contact winnebago at 614-585-6939.
Recall 04V-516: Engine and Engine Cooling
Problem: On motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.
Risk: These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire.
Fix: Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will inspect and replace the air filter element. Owners should contact ford at 1-800-392-3673 or winnebago at 641-585-3535.
Recall 04V-512: Electrical System
Problem: On motor homes built on ford e-series chassis and equipped with gas engines, a diode in the anti-lock braking system (Abs) module may experience an electrical short.
Risk: The electrical short may cause an ABS malfunction that would illuminate the ABS warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. This condition may occur while the vehicle is being driven or unattended.
Fix: Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will install a new fuse in the ABS circuit and install a heat shield over the ABS module. Owners should contact ford at 1-800-392-3673 or winnebago at 641-585-3535.
2005 Itasca Sundancer problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Engine and Engine Cooling | 1 |
Most reported parts
- Engine and Engine Cooling › Exhaust System — 1
Typical mileage at the time of the problem: 2,500 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Other Itasca Sundancer years
Frequently asked questions
Does the 2005 Itasca Sundancer have any recalls?
Yes — NHTSA lists 4 recalls for the 2005 Itasca Sundancer: 06V-456 (equipment), 05V-475 (fuel system, gasoline), 04V-516 (engine and engine cooling), 04V-512 (electrical system). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2005 Itasca Sundancer?
Owners report engine and engine cooling problems most often (1 reports). The typical mileage when problems were reported is about 2,500 miles.
Are Itasca recall repairs free?
Yes. Safety recall repairs are free at authorized Itasca dealers, whether you are the first owner or bought the car used.