2003 Itasca Suncruiser recalls and problems
The 2003 Itasca Suncruiser has 5 safety recalls and 4 owner complaints filed with NHTSA. Recall repairs are free at any Itasca dealer.
Recalls may cover only some 2003 Itasca Suncruiser vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2003 Itasca Suncruiser recalls
Recall 10V-525: Equipment
Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Recall 09V-300: Equipment
Problem: Winnebago is recalling 1,547 model year 2001-2003 recreational vehicles equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.
Risk: If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Fix: Winnebago is working with norcold and norcold will notify owners and the vehicle's refrigerator will be repaired free of charge (Please see 09e-027). Owners may contact norcold's recall center at 1-800-767-9101.
Recall 05V-407: Equipment
Problem: On certain motor homes, the roof vent for the optional 4-door refrigerator was incorrectly located.
Risk: This can allow excessive heat buildup which has the potential to ignite surrounding materials, resulting in personal injury and/oi vehicle and property damage.
Fix: Dealers will relocate the roof vent. The recall began on september 9, 2005. Owners may contact winnebago at 1-641-585-6939.
Recall 04V-609: Fuel System, Gasoline
Problem: On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
Risk: Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.
Recall 03V-060: Service Brakes, Hydraulic
Problem: Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105,"hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.
Risk: In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.
Fix: Dealers will repair these vehicles. Owner notification began april 25, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-3535.
2003 Itasca Suncruiser problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Service Brakes, Hydraulic | 3 | |
| Engine and Engine Cooling | 1 |
Typical mileage at the time of the problem: 18,674 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2003 Itasca Suncruiser complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Itasca Suncruiser years
Frequently asked questions
Does the 2003 Itasca Suncruiser have any recalls?
Yes — NHTSA lists 5 recalls for the 2003 Itasca Suncruiser: 10V-525 (equipment), 09V-300 (equipment), 05V-407 (equipment), 04V-609 (fuel system, gasoline), 03V-060 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2003 Itasca Suncruiser?
Owners report service brakes, hydraulic problems most often (3 reports), followed by engine and engine cooling (1). The typical mileage when problems were reported is about 18,674 miles.
Are Itasca recall repairs free?
Yes. Safety recall repairs are free at authorized Itasca dealers, whether you are the first owner or bought the car used.