2002 International 9900 recalls and problems
The 2002 International 9900 has 4 safety recalls. Recall repairs are free at any International dealer.
Recalls may cover only some 2002 International 9900 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2002 International 9900 recalls
Recall 07V-020: Electrical System
Problem: On certain trucks equipped with caterpillar c10, c11, c12, c13, c15 or c16 engines, the positive battery cables that supply power from the batteries to the starter may rub against an electrical ground cable between the engine and the starter, an electrical ground cable between the frame rail and the starter, or the frame rail itself.
Risk: This rubbing may cause an electrical short or a fire which can result in property damage, personal injury or death.
Fix: Dealers will inspect the battery cables to determine if any rubbing has occurred. New battery cables will be replaced as necessary. Dealers will also reroute the battery cables between the starter and battery box using new brackets. The recall began on april 20, 2007. Owners may contact international at 1-800-448-7825.
Recall 04V-482: Suspension
Problem: On certain heavy duty trucks,the lower tie rod arms on certain axles were not induction hardened as required by international's specification.
Risk: Without the induction hardening process being performed, the tie rod arm may fatigue during the expected life of the vehicle. A fatigue failure of the tie rod arm may result in a loss of vehicle steering control that can possibly result in a vehicle crash.
Fix: Dealers will inspect and replace the lower tie rod arms. The recall began on november 19, 2004. Owners should contact international truck and engine at 1-800-448-7825.
Recall 04V-100: Equipment
Problem: On certain conventional trucks equipped with pro-sleeper berths, water intrusion can be found in the bunk control panel area and pool in the tops of the dome light, tv/vcr, and or refrigerator power switches.
Risk: The circuit boards in the switches could heat up , possibly produce a flame or fire, and cause property damage, personal injury, or death.
Fix: Dealers will install a water shield over the back of the entire bunk control panel. Owner notification began on july 16, 2004. Owners should contact international at 1-800-448-7825.
Recall 02V-265: Steering
Problem: On certain heavy duty trucks, the joint between the lower portion of the steering column and the upper end of the intermediate steering shaft may have a missing or loose pinch bolt. This condition could also occur at the lower end of the intermediate steering shaft at the steering gear connection.
Risk: If a pinch bolt is missing or vibrates loose, the shaft could separate from the steering column or steering gear, and /or allow slippage between the joined shafts, increasing the risk of a crash.
Fix: Dealers will inspect both ends of the shaft to ensure the pinch bolt is installed and/or properly torqued. If the bolt and nut are missing, a new bolt, nut, and washer will be installed. Owner notification is expected to begin during september 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Other International 9900 years
Compare all International 9900 years · All International models
Frequently asked questions
Does the 2002 International 9900 have any recalls?
Yes — NHTSA lists 4 recalls for the 2002 International 9900: 07V-020 (electrical system), 04V-482 (suspension), 04V-100 (equipment), 02V-265 (steering). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are International recall repairs free?
Yes. Safety recall repairs are free at authorized International dealers, whether you are the first owner or bought the car used.