2003 International 8500 recalls and problems
The 2003 International 8500 has 3 safety recalls. Recall repairs are free at any International dealer.
Recalls may cover only some 2003 International 8500 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2003 International 8500 recalls
Recall 23V-353: Exterior Lighting
Problem: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Fix: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
Recall 05V-188: Trailer Hitches
Problem: On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. This could result in inadvertent operation of the fifth wheel slide control.
Risk: If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.
Fix: Dealers will relocate the msva 7-pack to a less water intensive environment. A new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. The recall began on august 5, 2005. Owners may contact international at 1-800-448-7825.
Recall 04V-306: Electrical System
Problem: On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar I-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
Risk: This could cause an electrical short and/or fire.
Fix: Dealers will inspect for any chafing. If there is no evidence of chafing, a saddle clamp will be installed. If there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. The recall began on august 16, 2004. Owners should contact international at 1-800-448-7825.
Other International 8500 years
Compare all International 8500 years · All International models
Frequently asked questions
Does the 2003 International 8500 have any recalls?
Yes — NHTSA lists 3 recalls for the 2003 International 8500: 23V-353 (exterior lighting), 05V-188 (trailer hitches), 04V-306 (electrical system). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
Are International recall repairs free?
Yes. Safety recall repairs are free at authorized International dealers, whether you are the first owner or bought the car used.