Home › Hyundai › Santa Fe Hybrid › 2023

2023 Hyundai Santa Fe Hybrid recalls and problems

The 2023 Hyundai Santa Fe Hybrid has 1 safety recall and 59 owner complaints filed with NHTSA. Recall repairs are free at any Hyundai dealer.

Urgent: recall 23V-181 carries a "park outside" warning. Contact a dealer before driving.
Recalls
1
Complaints
59
Crashes / fires
1 / 0
Injuries / deaths
2 / 0

Recalls may cover only some 2023 Hyundai Santa Fe Hybrid vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2023 Hyundai Santa Fe Hybrid recalls

Recall 23V-181: Trailer Hitches

Park outsideReported Mar 17, 2023 · 584,784 vehicles affected · Hyundai Motor America

Problem: Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

Fix: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

2023 Hyundai Santa Fe Hybrid problems reported by owners

Problem areaReports
Engine25
Power Train15
Electrical System15
Fuel/Propulsion System13
Unknown or Other11
Forward Collision Avoidance11
Vehicle Speed Control7
Lane Departure4
Service Brakes3
Structure2
Back Over Prevention2
Visibility2

Most reported parts

  • Forward Collision Avoidance › Automatic Emergency Braking — 10
  • Lane Departure › Blind Spot Detection — 4
  • Structure › Body — 2
  • Visibility › Sun/Moon Roof Assembly — 2
  • Back Over Prevention › Rearview System Braking — 1
  • Vehicle Speed Control › Accelerator Pedal — 1
  • Engine and Engine Cooling › Cooling System › Radiator Assembly — 1
  • Forward Collision Avoidance › Warnings — 1

Typical mileage at the time of the problem: 23,824 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2023 Hyundai Santa Fe Hybrid complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · reported Nov 10, 2026
I am filing this complaint regarding an EGR valve failure in my 2023 Hyundai Santa Fe Hybrid, VIN [XXX]. My vehicle experienced an EGR valve malfunction at approximately 93,500 miles. The Hyundai dealership diagnosed the EGR valve with an internal fault and replaced it. I had to pay approximately $1,700 out of pocket because Hyundai declined warranty assistance based on the vehicle's mileage. My vehicle is also associated with Hyundai Service Campaign 9C7, which addresses improvements to the Engine Control Module (ECM) software related to EGR system operation. I understand that Campaign 9C7…
Engine · reported Oct 10, 2026
The vehicle came to a complete stop filling cabin with smoke and wouldnt start in a bend on road blocking entrance ramp. Its available for inspection but at dealership. My safety was put at risk for collision as well as health with cabin filling with smoke. The dealer still has vehicle going on 3rd day without answers. The vehicle had warning come on for hybrid system failure appearing shortly before dying completely with smoke filling cabin.
Structure · reported Jun 3, 2026
I am submitting this formal safety complaint regarding a structural defect in my 2023 Hyundai Santa Fe Hybrid that I believe poses a safety concern and warrants federal investigation under the National Traffic and Motor Vehicle Safety Act (49 U.S.C. § 30101 et seq.). The vehicle exhibits a persistent and recurring structural creak originating from the pinch weld area adjacent to the hybrid battery storage compartment — specifically at a metal-on-metal contact point above the rear driver-side wheel well. The noise presents most prominently at low speeds over uneven surfaces, driveway…
Electrical System · reported Dec 21, 2025
One two separate occasions while driving the car has lost the ability to accelerate. There is no acceleration power even when completely flooring the gas pedal. The dash displays a red circle warming that states "Check Hybrid system. Stop Safely". I have had to coast to the side of the road and then the car shuts off. It has taken several minutes before it can start again, and then displays a warning "Park with engine On to charge battery" before being able to shift the car into drive. I immediately took the vehicle to the dealership at which I had purchased the car. They have run a diagnostic…
Fuel/Propulsion System · reported Dec 14, 2025
The vehicle will not accelerate and comes to a complete stop while driving. Within days, it displayed ‘Check Hybrid System. Stop safely’ and lost propulsion while driving.

Other Hyundai Santa Fe Hybrid years

202620252024202320222021

Compare all Hyundai Santa Fe Hybrid years · All Hyundai models

Frequently asked questions

Does the 2023 Hyundai Santa Fe Hybrid have any recalls?

Yes — NHTSA lists 1 recall for the 2023 Hyundai Santa Fe Hybrid: 23V-181 (trailer hitches). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2023 Hyundai Santa Fe Hybrid?

Owners report engine problems most often (25 reports), followed by power train (15). The typical mileage when problems were reported is about 23,824 miles.

Are Hyundai recall repairs free?

Yes. Safety recall repairs are free at authorized Hyundai dealers, whether you are the first owner or bought the car used.