2002 Honda VFR800 recalls and problems

The 2002 Honda VFR800 has 2 safety recalls and 6 owner complaints filed with NHTSA. Recall repairs are free at any Honda dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2002 Honda VFR800 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 Honda VFR800 recalls

Recall 07V-359: Electrical System

Reported Aug 15, 2007 · 6,952 vehicles affected · HONDA (AMERICAN HONDA MOTOR CO.)

Problem: On certain motorcycles, the front fairing sub-harness (Section of the wiring harness) transfers the electrical grounding load of the headlights, front turn signals, instrument panel, and various relays to the main wiring harness via an 18-pin connector. Under certain conditions, the ground wire terminals inside the connector can overheat, resulting in melting of the connector and a loss of power to various circuits.

Risk: As a result, a loss of critical lighting or engine power could occur without warning, which could cause a crash.

Fix: Dealers will install a re-designed sub-harness. If damage is found, the main wiring harness will also be replaced free of charge. An interim letter was mailed to owners on september 26, 2007. Owners were re-notified on november 10, 2007, to take their motorcycles to dealers to have the parts installed. Owners may contact honda at 1-866-784-1870.

Recall 05V-010: Service Brakes, Hydraulic

Reported Jan 24, 2005 · 36,046 vehicles affected · HONDA (AMERICAN HONDA MOTOR CO.)

Problem: Certain motorcycles equipped with combined-brake systems have a proportioning control valve (Pcv) that mechanically proportions brake force when the rear brake is applied. A seal in some pcvs is improperly shaped, and brake fluid leakage may occur.

Risk: If the motorcycle continues to be used after a leak occurs, the rear brake would eventually become inoperative. A loss of rear brake force could increase the risk of a crash.

Fix: Dealers will inspect the rear brake forleakage. If leakage is confirmed, the dealer will replace the pcv free of charge. The recall began on january 31, 2005. Owners may contact honda at 866-784-1870.

2002 Honda VFR800 problems reported by owners

Problem area	Reports
Electrical System	5
Exterior Lighting	2
Engine and Engine Cooling	1
Unknown or Other	1

Most reported parts

Electrical System › Wiring › Fuses and Circuit Breakers — 2
Electrical System › Wiring — 1
Exterior Lighting › Headlights — 1
Exterior Lighting › Turn Signal — 1

Typical mileage at the time of the problem: 20,054 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 Honda VFR800 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Unknown or Other · reported Jul 17, 2008

The contact owns a 2002 honda vfr800. The contact mailed in a warranty card notifying the honda manufacturer that he now owns the motorcycle. The warranty information was entered into honda's system incorrectly and now it states that the motorcycle is stolen. There is a NHTSA campaign id number 07v359000 (Electrical system:wiring) on the vehicle, which the dealers are refusing to acknowledge due to their error. There had been no failure to date.

Electrical System · at 17,000 miles · reported May 23, 2007

I own a 2002 honda vfr 800 motorcycle that has incurred electrical problems that 2 dealers were unable to repair. The electrical problems occurred while I was driving on the highway at highway speeds, and when trying to use turn signals. The headlights went out and the engine died...a very dangerous situation. Now the motorcycle still did the same thing, just that the headlights were practically non functioning ,they came on sometimes when going over a bump but the engines still died whenever I use the turn signals. Any help you may provide would be greatly appreciated, the more research I do…

Electrical System · at 9,000 miles · reported Oct 3, 2006

Motorcycle engine died while running. I did troubleshoot to find an electrical 30 amp fuse wire insulation scorched and burned through. Copper conductor had become very hot.

Electrical System · at 20,054 miles · reported Sep 11, 2006

Had starting problems and went to check the battery. Found that the fuse holder, a connector and the small wire between the two had discolored to a brown. There were signs of melting on the wire insulation. The part has not failed to date but gets very hot to the touch when the vehicle engine is running.

Electrical System · at 43,000 miles · reported Jul 25, 2005

Dt: the consumer experienced 4 separate electrical failures, it has caused headlight and engine failure. The consumer contacted honda they have repaired the issue under warranty. The ground wire has burned 3 times at different points. The 1st time aug 2002. First time it only had 18,000 miles.

Other Honda VFR800 years

2006 2005 2004 20032002

Compare all Honda VFR800 years · All Honda models

Frequently asked questions

Does the 2002 Honda VFR800 have any recalls?

Yes — NHTSA lists 2 recalls for the 2002 Honda VFR800: 07V-359 (electrical system), 05V-010 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2002 Honda VFR800?

Owners report electrical system problems most often (5 reports), followed by exterior lighting (2). The typical mileage when problems were reported is about 20,054 miles.

Are Honda recall repairs free?

Yes. Safety recall repairs are free at authorized Honda dealers, whether you are the first owner or bought the car used.