2008 Harley-Davidson Fxdc recalls
Reported Nov 20, 2007 · 538 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY
Problem: On certain motorcycles built and shipped to california, the catalytic muffler protective heat shield was not installed. This condition could allow direct contact with this muffler and cause injury.
Risk: If contact occurs while riding, it could cause loss of control of the motorcycle, leading to injury or death.
Fix: Dealers will install the heat shields to the mufflers free of charge. The recall began on november 26, 2007. Owners may contact harley davidson at 1-414-343-4056.
2008 Harley-Davidson Fxdc problems reported by owners
| Problem area | Reports | |
|---|
| Fuel System, Gasoline | 2 | |
| Electrical System | 2 | |
| Fuel System, Other | 1 | |
| Power Train | 1 | |
| Service Brakes, Hydraulic | 1 | |
| Wheels | 1 | |
| Service Brakes | 1 | |
| Exterior Lighting | 1 | |
Typical mileage at the time of the problem: 12,639 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2008 Harley-Davidson Fxdc complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Service Brakes · reported Dec 9, 2024
The rear brake light switch failed. Yes it is available for inspection - Iâll hold onto the part after repair. My safety was put at risk when the switch failed causing a leak in brake fluid and a loss of pressure in the pedal. Losing my rear break functionality entirely. Then the leaking brake fluid went into the electrical connections on the switch and caught on fire. Not confirmed by a dealer but has happened on other Harley models and been recalled before just not for this model of bike. Not inspected by any of the listed. No warning notifications I just hit the pedal one day and it went…
Wheels · at 18,000 miles · reported Jul 18, 2014
Motorcycle began to exhibit noise at various speeds and rear wheel began losing tread at alarming rate. After propping the motorcycle up and removing the rear wheel to replace the tire, it was discovered that both rear wheel bearings had begun to deteriorate. Left side bearing was almost completely gone and the right side bearing showed signs of rust and damage. Replace both bearing with factory new and replaced tire. 8000 miles later the rear tire again began to loose tread. Removed and replace tire a second time and replaced back onto motorcycle without changing bearings. At approximately…
Electrical System · at 12,639 miles · reported Jul 10, 2011
The gas gauge failed this is the second time that this part has failed on my motorcycle. The first incident was in july 2009 which they replaced under warranty. The gauge gives false readings, it will show full and various other readings regardless of the amount of fuel in the tank. For example I filled the tank and it read full then 10 miles later it went to empty and showed remaining miles to empty as 25. This is a known problem and harley davidson still hasn't come up with a fix.
Electrical System · at 12,950 miles · reported Jul 10, 2011
Cruising at 40 MPH and applied rear and front brakes. There was no tension when applied continued a quarter mile and turned onto street of my house applied brakes and there was no rear brake response. Upon stopping in my driveway using the front brakes, I got off the bike and there was a fire at the rear brake relay switch and brake line. I had to put out this fire and brake fluid continued to leak. I believe this is a design defect, the relay switch is 1 inch from the exhaust and believe this was part of the failure the heat source being so close. I also noticed the brake master cylinder had…
Power Train · at 1,000 miles · reported Jun 8, 2010
The contact owns a 2008 harley davidson rocker fxcw motorcycle. The contact stated that while accelerating at approximate speeds of 50 MPH, the vehicle lost all power and stalled. The vehicle was towed to the dealer for repairs. The dealer stated that the bolts supporting the drive sprockets to the rear wheel completely separated from the hub. The vehicle was left with the dealer where the contact was awaiting repairs at the contact's expense. The failure and current mileages were approximately 1,000.
Frequently asked questions
Does the 2008 Harley-Davidson Fxdc have any recalls?
Yes — NHTSA lists 1 recall for the 2008 Harley-Davidson Fxdc: 07V-535 (engine and engine cooling). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2008 Harley-Davidson Fxdc?
Owners report fuel system, gasoline problems most often (2 reports), followed by electrical system (2). The typical mileage when problems were reported is about 12,639 miles.
Are Harley-Davidson recall repairs free?
Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.