2009 Harley-Davidson Fxdb recalls and problems

The 2009 Harley-Davidson Fxdb has 2 safety recalls and 17 owner complaints filed with NHTSA. Recall repairs are free at any Harley-Davidson dealer.

Recalls

Complaints

Crashes / fires

2 / 0

Injuries / deaths

2 / 0

Recalls may cover only some 2009 Harley-Davidson Fxdb vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2009 Harley-Davidson Fxdb recalls

Recall 08V-659: Structure

Reported Dec 15, 2008 · 3,285 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: Harley-davidson is recalling 3,285 my 2009 fxd, fxdf, fxdc, fxdl, and fxdb motorcycles. The jiffy stand spring anchor may have been built with a defective weld that may allow the jiffy stand assembly to not retract as intended.

Risk: This condition could lead to a crash which could cause injury or death to the rider.

Fix: Dealers will remove the original jiffy stand spring anchor and replace it with a new spring anchor free of charge. The recall is expected to begin on or about december 22, 2008. Owners may contact harley-davidson at 1-414-342-4680.

Recall 08V-625: Fuel System, Gasoline

Reported Nov 26, 2008 · 349 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: Harley-davidson is recalling 349 my 2009 fxdb, fxdc, fxdf, and fxdl motorcycles. These motorcycles have a fuel tank vent tube assembly, part no. 27389-04a, which may have been produced with a defective ultrasonic weld on the anti-slosh valve.

Risk: If the valve separates and the bike is tipped over, it may leak fuel. Fuel leakage in the presence of an ignition source could result in a fire.

Fix: Dealers will inspect the fuel vent tube assembly and, if necessary, replace it. The recall is expected to begin on or about december 8, 2008. Owners may contact harley-davidson at 1-414-343-4056.

2009 Harley-Davidson Fxdb problems reported by owners

Problem area	Reports
Engine and Engine Cooling	4
Tires	3
Service Brakes, Hydraulic	3
Fuel System, Gasoline	1
Suspension	1
Vehicle Speed Control	1
Electrical System	1
Fuel System, Other	1
Fuel/Propulsion System	1
Structure	1
Wheels	1

Most reported parts

Engine and Engine Cooling › Exhaust System › Manifold/Header/Muffler/Tail Pipe — 1
Engine and Engine Cooling › Exhaust System — 1
Fuel System, Other › Storage › Fuel Gauge System — 1
Structure › Body — 1

Typical mileage at the time of the problem: 6,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2009 Harley-Davidson Fxdb complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Wheels · at 8,000 miles · reported Jun 12, 2014

Message: to who it may concern, has anyone every mentioned the problem with harley davidson model fat bob 2008 and on, the problem with the front tire dunlap 427 made especially for fat bob cupping (Lumping of tread) causing vibrations bad uneven wear can cause front tire not flush to pavement in cornering. Every hd fat bob bikes I have come across has this same problem. My own guess it is caused by front fork suspension/springs not correct.my tire pressures are always checked at least 2 times per week ...so it is not caused by under or over inflation.

Structure · at 13,500 miles · reported Dec 3, 2013

I actually have a 2009 harley-davidson super glide custom (Fxdc) with a harley-davidson street bob (Fxdb) rear fender assembly. The rear fender was installed in 2011 by a harley-davidson dealership in daytona beach, florida. Since I had the rear fender installed, I have put approximately 2000 miles on the motorcycle. On november 16, 2013, I was washing the motorcycle and notices a split in the rear fender at the light assembly, starting at the rear bottom and running up the back of the fender, to the right and parallel to the light assembly. In researching this problem, I have found numerous…

Fuel/Propulsion System · at 22,000 miles · reported May 6, 2013

When the motorcycle is parked and the ambient temperature begins to rise, usually around 80 degrees f and up, there is a steady drip of gas from the tank overflow tube. This occurs with the fuel level at full, 3/4, 1/2 and sometimes even lower. I have taken the bike in to the local hd dealership(04/30/2013) and they replaced an anti-slosh valve and fuel cap and inspected the other components on the bike with no improvements. Reading on various forums this issue is noted several times with no solutions noted currently. I have contacted hd customer service(05/06/2013) and was told to take the…

Fuel System, Other · at 1 miles · reported Aug 2, 2011

The bikes fuel gauge has never worked since the original purchase of this bike. It has never been taken to a dealer to be "fixed" because after doing some research it appears that there is no fix for the faulty gauge.

Electrical System · at 6,000 miles · reported Apr 30, 2011

Dear sirs: on december 5, 2010 while making a left turn into a driveway my harley davidson tri-glide (Vin [xxx]) model flhtcutg (This model # was not allowed in a following field) accelerated unexpectedly and tipped on its side throwing me off and then into a fence. I was transported from the scene by ambulance with minor injuries (Broken ribs) and the bike was towed to a storage yard. The next day I called harley davidson of sacramento to arrange for the bike to be towed there and repaired. I was told by them that they did not perform insurance repairs and was referred to mid-cal cycle of…

Other Harley-Davidson Fxdb years

20092008 2007

Compare all Harley-Davidson Fxdb years · All Harley-Davidson models

Frequently asked questions

Does the 2009 Harley-Davidson Fxdb have any recalls?

Yes — NHTSA lists 2 recalls for the 2009 Harley-Davidson Fxdb: 08V-659 (structure), 08V-625 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2009 Harley-Davidson Fxdb?

Owners report engine and engine cooling problems most often (4 reports), followed by tires (3). The typical mileage when problems were reported is about 6,000 miles.

Are Harley-Davidson recall repairs free?

Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.