2008 Harley-Davidson FXD recalls
Reported Nov 20, 2007 · 538 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY
Problem: On certain motorcycles built and shipped to california, the catalytic muffler protective heat shield was not installed. This condition could allow direct contact with this muffler and cause injury.
Risk: If contact occurs while riding, it could cause loss of control of the motorcycle, leading to injury or death.
Fix: Dealers will install the heat shields to the mufflers free of charge. The recall began on november 26, 2007. Owners may contact harley davidson at 1-414-343-4056.
2008 Harley-Davidson FXD problems reported by owners
| Problem area | Reports | |
|---|
| Fuel System, Gasoline | 3 | |
| Fuel System, Other | 2 | |
| Service Brakes, Hydraulic | 1 | |
| Suspension | 1 | |
Most reported parts
Typical mileage at the time of the problem: 2,100 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2008 Harley-Davidson FXD complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Suspension · at 8,368 miles · reported May 10, 2011
2008 harley davidson fxd dyna super glyde. Consumer writes in regards to wheel bearing problems the consumer stated at 8368 miles, the rear wheel bearing failed. The mechanic informed the consumer it was a common problem with all the 2008 and newer models. The consumer stated the manufacturer changed the bearing from 1 inch to 25mm.
Fuel System, Gasoline · at 1,200 miles · reported Oct 6, 2010
The contact owns a 2008 harley davidson night rider special motorcycle (Na). While driving 45 MPH, the vehicle suddenly ran out of fuel. The contact stated that the fuel gauge indicated that the tank was full. The failure had occurred since april 2008. The vehicle was taken to an authorized dealer where the fuel sending unit was replaced. The failure occurred again a few weeks later. The contact had to set the trip odometer after he fueled to monitor the amount of fuel in the tank. The vehicle had not been repaired again. The VIN was unavailable. The failure mileage was approximately 1,200 and…
Fuel System, Gasoline · at 78 miles · reported Jul 22, 2010
My brand new 2008 harley davidson night rod (Vrscd) came with a faulty fuel gauge (Sender). Took it into the dealership for a warranty replacement. The gauge (Sender) was replaced, but the problem continued. The gauge displays incorrectly all the time. I'm resorting to resetting the trip odometer at every fill-up to endure that I don't run out of fuel. For $17,000 dollars you'd think a company that has been in business for over a century could get a simple thing like this figured out. ( There was no model listed in the pulldown menu to select from on this form, so I had no choice but to select…
Fuel System, Other · at 3,400 miles · reported Jul 1, 2008
Fuel pump on 2008 harley ultra classic caused pipes to get so hot ( Glowing red )when I checked oil level the rag I was using caught on fire. Also the pipes are now really discolored and harley won't replace them back to original condition. They won't even change the oil that I'm sure was broken down by the heat.
Fuel System, Other · at 500 miles · reported May 30, 2008
Uncontrollable idle, harley davidson fly by wire throttle. Idle intermittently will go above 1800 RPM. A factory known issue with no permanent repair or replacement. I have had this bike 2 months now it it has happened at least 8 times. Dealership said it was how I turned my bike off. They said to turn the ignition on and off 2-3 times to reset the throttle position problem is in the fly by wire circuit and computer which looses memory and goes into a high RPM. The experience is like cruise control being turned on and you cannot slow down when you release the throttle.... . This has had mixed…
Frequently asked questions
Does the 2008 Harley-Davidson FXD have any recalls?
Yes — NHTSA lists 1 recall for the 2008 Harley-Davidson FXD: 07V-535 (engine and engine cooling). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2008 Harley-Davidson FXD?
Owners report fuel system, gasoline problems most often (3 reports), followed by fuel system, other (2). The typical mileage when problems were reported is about 2,100 miles.
Are Harley-Davidson recall repairs free?
Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.