2009 Harley-Davidson FLHTCUTG recalls and problems

The 2009 Harley-Davidson FLHTCUTG has 2 safety recalls and 5 owner complaints filed with NHTSA. Recall repairs are free at any Harley-Davidson dealer.

Recalls

Complaints

Crashes / fires

0 / 1

Injuries / deaths

1 / 0

Recalls may cover only some 2009 Harley-Davidson FLHTCUTG vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2009 Harley-Davidson FLHTCUTG recalls

Recall 11V-506: Exterior Lighting

Reported Oct 19, 2011 · 250,757 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: Harley-davidson is recalling certain model year 2009-2012 touring, cvo touring and trike vehicles manufactured from june 6, 2008, through september 16, 2011. See the above list for the models included in the recall. The rear brake light switch may be exposed to excessive heat from the exhaust system.

Risk: The excessive heat may cause the switch to not activate the brake lamp or activate the brake lamp when no brake is applied and/or cause a brake fluid leak at the brake light switch, affecting rear brake performance. Either condition may increase the risk of a crash.

Fix: Harley-davidson will notify owners, and dealers will a install a rear brake light switch kit, free of charge. The safety recall is expected to begin during october 31, 2011. Owners may contact harley-davidson at 1-414-343-4056.

Recall 09V-457: Fuel System, Gasoline

Reported Dec 1, 2009 · 111,569 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: Harley-davidson is recalling certain model year 2009 and 2010 touring family motorcycles, including cvo touring and trike products, manufactured from june 6, 2008 through november 19, 2009. The front fuel tank mounts may distort in reaction to severe frame damage from a frontal collision. This condition may cause a fuel leak at the weld of the front bracket to the tunnel.

Risk: A fuel leak in the presence of an ignition source may result in a fire, which could lead to injury or death to the rider.

Fix: Dealers will install a left and right brace, which are intended to reduce front mount distortion during certain crash conditions. This repair will be performed free of charge. The safety recall began on december 11, 2009. Owners may contact harley-davidson at 1-414-343-4056.

2009 Harley-Davidson FLHTCUTG problems reported by owners

Problem area	Reports
Engine and Engine Cooling	2
Fuel System, Gasoline	1
Engine	1
Service Brakes	1

Most reported parts

Engine and Engine Cooling › Exhaust System — 1
Engine and Engine Cooling › Engine — 1

Typical mileage at the time of the problem: 1,500 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2009 Harley-Davidson FLHTCUTG complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes · at 25 miles · reported Feb 9, 2018

The rear brakes on a 2009 hd trike has very little stopping power,harley knows it has a problem because they started putting bigger brakes on the 2011 models. I thought that they would have to fix the 2009,and 2010 models.but there never was a recall on them.there is a safety problem when you can't stop. Plus now my rear brakes quit working all together.

Engine · at 10,219 miles · reported Aug 19, 2013

The contact owns a 2009 harley davidson flhtcutg. The contact stated while driving various speed there was a slight vibration which caused two bolts to detach from the exhaust. The vehicle was taken to an authorized dealer who stated that the engine mount dislodged and the head would need to be replaced for the second time. The vehicle would be repaired under the service warranty once the part became available. The manufacturer was not notified of the problem. The approximate failure mileage was 10,219.

Fuel System, Gasoline · at 1,500 miles · reported Oct 31, 2011

On the above date this vehicle caught on fire less than a minute after starting it. I had rode this vehicle to work and was at work for around two hours. Upon leaving work, I started the motorcycle without getting on and was reaching to put items in the trunk when the fire started. When walking up to the vehicle I did not smell gasoline or notice any leaking fuel before starting the motorcycle. The motorcycle was engulfed in flames very quickly. I was very close to being burned. Some co-workers and myself attempted to put out the fire, but were unable to get close enough due to the intense…

Engine and Engine Cooling · at 4,000 miles · reported Jul 6, 2011

Rider experienced 2nd degree burns due to heat emanating from the engine during hot weather and stop-and-go traffic; rear cylinder shuts off and then motorcycle runs poorly (No acceleration); also affects braking (Rear brake gets "mushy"); has resulted in discoloration of horn and air filer cover; oil pressure drops to 0; have had to replace 2 qts. Of oil in 1300 miles; literally was "smoking"; ambient temp. Pegged out at 120 degrees. Extreme safety hazard to rider and dealer can offer no solution; can't even tune the motorcycle because they can't dyno a trike.

Engine and Engine Cooling · at 10 miles · reported May 15, 2011

Heat coming off the exhaust/engine makes the bike unbearable to ride...especially when the weather gets warmer and you are stopped or going slowly in traffic. It will burn your right calf severely and harley davisdon refuses to admit the problem or offer a remedy for it. Also rear brakes squeal constantly and are barely adequate for stopping.

Other Harley-Davidson FLHTCUTG years

2022 2021 2020 2019 2018 2017 2015 2014 2013 2012 2011 20102009

Compare all Harley-Davidson FLHTCUTG years · All Harley-Davidson models

Frequently asked questions

Does the 2009 Harley-Davidson FLHTCUTG have any recalls?

Yes — NHTSA lists 2 recalls for the 2009 Harley-Davidson FLHTCUTG: 11V-506 (exterior lighting), 09V-457 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2009 Harley-Davidson FLHTCUTG?

Owners report engine and engine cooling problems most often (2 reports), followed by fuel system, gasoline (1). The typical mileage when problems were reported is about 1,500 miles.

Are Harley-Davidson recall repairs free?

Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.