There are no safety recalls for the 2007 Harley-Davidson FLHTC, but owners have filed 14 complaints with NHTSA.
2007 Harley-Davidson FLHTC problems reported by owners
| Problem area | Reports | |
|---|
| Engine and Engine Cooling | 6 | |
| Power Train | 5 | |
| Exterior Lighting | 2 | |
| Electrical System | 1 | |
| Tires | 1 | |
| Service Brakes | 1 | |
Most reported parts
- Power Train › Manual Transmission — 3
- Engine and Engine Cooling › Exhaust System › Manifold/Header/Muffler/Tail Pipe — 2
- Engine and Engine Cooling › Engine — 1
- Engine and Engine Cooling › Exhaust System — 1
- Exterior Lighting › Brake Lights › Switch — 1
Typical mileage at the time of the problem: 7,600 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2007 Harley-Davidson FLHTC complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Power Train · at 60,000 miles · reported Dec 29, 2016
The contact owns a 2007 harley-davidson flhtc. While riding 75-80 MPH, an abnormal noise emitted from the transmission. The dealer diagnosed that the transmission needed to be replaced. The motorcycle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000. Updated 04/06/17 lj
Service Brakes · at 35,000 miles · reported Sep 28, 2014
The rear brake line (Pn 40971-00a) rubbed the frame and clutch cable, causing a hole to be created. This is in the area below the cam chest, behind the master cylinder, inside the frame on the right side. The brake line blew out when the rear brake was applied. There was no warning. After doing research, I found this to be a common problem.
Exterior Lighting · at 43,000 miles · reported Sep 5, 2014
The contact owns a 2007 harley davidson flhtc. The contact stated that while driving at 9 MPH, the brake lamp failed to activate when the brake pedal was depressed. The contact mentioned that the brake lamp switch was melted. The vehicle was taken to a dealer where it was diagnosed that the brake light switch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the VIN number was not included in NHTSA campaign number: 11v506000 (Exterior lighting). The failure mileage was 43,000.
Power Train · at 27,737 miles · reported Jul 24, 2014
As I was slowing down in my driveway the engine, with out warning, made a loud metallic noise from the left side and locked up along with the rear wheel. If this would have happened at a greater speed, or in traffic, the consequences could have been dire. I removed the primary cover and immediately notice a large piece of steel had gotten jammed between the clutch sprocket and primary drive chain. This large piece of steel had broken off a pressed steel cage that enclosed a set of diaphragm springs from the crankshaft compensator assembly. The outer edge of the springs, over time, had worn…
Tires · at 7,600 miles · reported Mar 19, 2013
While riding the motorcycle (2007 harley davidson heritage softail classic) at 57 MPH on dry pavement with no adverse road conditions, the rear tire blew, the rider fought to keep the bike upright to slow down for 3-5 seconds, then lost control and crashed on the highway. The tire pressure was checked to proper inflation 30 minutes before the blowout and accident occurred. The rider suffered a brain conclusion with minor hemorrhaging, a broken collarbone, and broken bones in the right foot. The tire, which was new on the bike and purchased two months before the accident, had only been ridden…
Frequently asked questions
Does the 2007 Harley-Davidson FLHTC have any recalls?
No. NHTSA has no safety recalls for the 2007 Harley-Davidson FLHTC as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2007 Harley-Davidson FLHTC?
Owners report engine and engine cooling problems most often (6 reports), followed by power train (5). The typical mileage when problems were reported is about 7,600 miles.
Are Harley-Davidson recall repairs free?
Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.