2004 Harley-Davidson Dyna Glide recalls and problems

The 2004 Harley-Davidson Dyna Glide has 2 safety recalls and 5 owner complaints filed with NHTSA. Recall repairs are free at any Harley-Davidson dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2004 Harley-Davidson Dyna Glide vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 Harley-Davidson Dyna Glide recalls

Recall 04V-465: Fuel System, Gasoline

Reported Sep 30, 2004 · 2,828 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: On certain motorcycles, a condition occurs that could allow pressure to build up in the fuel tank. On fuel injected vehicles, this condition could cause fuel to spray out unexpectedly when the fuel cap is removed. On carbureted vehicles, excessive fuel could be transferred to the carburetor, which would eventually allow fuel to drip from the air cleaner.

Risk: These situations could cause serious personal injury or create a fire hazard for persons or property on or near the motorcycle.

Fix: Dealers will test each canister for blockage, then replace as necessary. The recall began november 4, 2004. Owners should contact harley-davidson at 1-414-343-4056.

Recall 04V-052: Fuel System, Gasoline

Reported Feb 2, 2004 · 4,593 vehicles affected · HARLEY-DAVIDSON MOTOR COMPANY

Problem: On certain fuel injected motorcycles, the rubber fuel hose has the potential to separate from the inner liner causing a fuel leak.

Risk: This could result in a fire.

Fix: Dealers will replace the fuel line assembly. Owner notification began on february 12, 2004. Owners should contact harley-davidson at 1-414-342-4680.

2004 Harley-Davidson Dyna Glide problems reported by owners

Problem area	Reports
Power Train	2
Service Brakes, Hydraulic	1
Suspension	1
Fuel System, Gasoline	1

Most reported parts

Power Train › Clutch Assembly — 1
Power Train › Manual Transmission — 1
Service Brakes, Hydraulic › Foundation Components › Drum — 1
Suspension › Front › Wheel Bearing — 1
Fuel System, Gasoline › Storage › Tank Assembly — 1

Typical mileage at the time of the problem: 844 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 Harley-Davidson Dyna Glide complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Fuel System, Gasoline · at 7,000 miles · reported Nov 15, 2005

Dt: the contact received NHTSA recall 04v465000 concerning the fuel tank storage assembly. Thwere not available. The dealership told her the parts may not be available for at least six more weeks..

Suspension · at 844 miles · reported Oct 6, 2004

Consumer just purchased a new harley-davidson, and the front wheel bearings were defective, causing the front wheel to wobble. This problem occurred once at 844 miles. Then, it happened again at 1149 miles. The consumer had the motorcycle repaired spacer was in the front wheel .

Power Train · at 195 miles · reported Aug 5, 2004

While motorcycle was parked consumer noticed fluid leaking from underneath. Consumer contacted the dealer to make an appointment for repairs. The leak occurred in front of the rear tire which resulted in some of the fluid getting on the tire. The dealer has worked on the transmission 3 times and has replaced 6 o-rings in an attempt to correct the problem. The shifter peg fell of while the consumer was on the way to the dealer. This almost caused an accident because the driver was unable to shift the motorcycle.

Service Brakes, Hydraulic · at 400 miles · reported Jul 30, 2004

The rear brakes were not properly lubricated, which resulted in the rear brakes locking up and causing control problems.

Power Train · at 1,600 miles · reported Apr 27, 2004

I was riding down the interstate and the clutch bolt flew out of the derby cover I was lucky that it flew out insted of in the gear that would have locked my back wheele up and I would have crashed I took it to the harley shop of wytheville va and they told me it was unchecked by the harley shop of roanoke va of were I purchased it from the bike is a 2004 model and has1600 miles on it.

Other Harley-Davidson Dyna Glide years

20042001 2000

Compare all Harley-Davidson Dyna Glide years · All Harley-Davidson models

Frequently asked questions

Does the 2004 Harley-Davidson Dyna Glide have any recalls?

Yes — NHTSA lists 2 recalls for the 2004 Harley-Davidson Dyna Glide: 04V-465 (fuel system, gasoline), 04V-052 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 Harley-Davidson Dyna Glide?

Owners report power train problems most often (2 reports), followed by service brakes, hydraulic (1). The typical mileage when problems were reported is about 844 miles.

Are Harley-Davidson recall repairs free?

Yes. Safety recall repairs are free at authorized Harley-Davidson dealers, whether you are the first owner or bought the car used.