2003 GMC C4500 recalls and problems

The 2003 GMC C4500 has 1 safety recall and 6 owner complaints filed with NHTSA. Recall repairs are free at any GMC dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2003 GMC C4500 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2003 GMC C4500 recalls

Recall 02V-202: Suspension

Reported Jul 26, 2002 · 952 vehicles affected · GENERAL MOTORS CORP.

Problem: Certain medium duty trucks equipped with 11,000 lb. Rear axle have a condition where the rear axle anchor plate may fracture. As the anchor plate fractures, there is an audible "bang." if this indication of a condition requiring the driver's attention went unnoticed or was ignored, and under certain rebound, braking, or cornering maneuvers, the rear axle would be free to move fore and aft and provide unexpected steering inputs to the vehicle.

Risk: If this happens while the vehicle is moving, a crash could result.

Fix: Dealers will install a new rear axle anchor plate and spacer. Owner notification began august 16, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.

2003 GMC C4500 problems reported by owners

Problem area	Reports
Service Brakes, Hydraulic	2
Power Train	2
Exterior Lighting	1
Engine and Engine Cooling	1
Tires	1

Most reported parts

Exterior Lighting › Headlights — 1
Service Brakes, Hydraulic › Power Assist › Hydraulic — 1
Power Train › Driveline › Differential Unit — 1
Service Brakes, Hydraulic › Foundation Components › Disc › Caliper — 1

Typical mileage at the time of the problem: 180,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2003 GMC C4500 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Tires · at 240,000 miles · reported Apr 12, 2010

Purchases tires in june 2009 -- upon inspection this weekend 4/11/2010 we noticed large cracks in the tires almost like it was separating. We brought them to the dealer and they charged us $100 to replace them after admitting that the tires had failed and were defective.

Power Train · at 180,000 miles · reported Oct 5, 2006

Throw bearing wears out every 40,000 KM. Bell housing gone at 180,000 KM's, rear end wore out at 182,000 kms and forth gear gone in transmission at 183,000, dash cluster gone at 188,000. Manufacture or dealer would not cover anything.

Engine and Engine Cooling · reported Mar 10, 2005

Vehicle experienced sudden stalling at various speeds when on the road. Taken to the dealer 10 times for checkup, but the cause was still undetermined.

Power Train · at 3,300 miles · reported Mar 8, 2005

Vehicle was experiencing a problem with grease from the rear end leaking onto the left rear wheel braking system. This caused loss of braking in that wheel. Dealer replaced the grease seal with an upgraded seal six times, problem recurred. Real grease seal was replaced. The driver side brake caliper bolt fell out causing the caliper to rub the inside of the inner dual wheel causing damage to the caliper and wheel.

Service Brakes, Hydraulic · at 79,000 miles · reported Oct 17, 2004

My engine stalled due to contaminated fuel. With the key still in the on position, I attempted to stop. I pressed the service brake pedal. The backup brake system did not operate. I repeated pressing the brake pedal two more times. I understood. I was closing the distance between my vehicle and the one in front of me approaching the traffic signal, red. The brake pedal switch failed to initiate the relays and pump. Consequently, the vehicle had practically no brakes other than the drum brake by hand brake handle. I applied the hand brake. Good thing I was only traveling at less than 30 miles…

Other GMC C4500 years

20062003

Compare all GMC C4500 years · All GMC models

Frequently asked questions

Does the 2003 GMC C4500 have any recalls?

Yes — NHTSA lists 1 recall for the 2003 GMC C4500: 02V-202 (suspension). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2003 GMC C4500?

Owners report service brakes, hydraulic problems most often (2 reports), followed by power train (2). The typical mileage when problems were reported is about 180,000 miles.

Are GMC recall repairs free?

Yes. Safety recall repairs are free at authorized GMC dealers, whether you are the first owner or bought the car used.