2003 Gem NEV recalls and problems

The 2003 Gem NEV has 1 safety recall and 2 owner complaints filed with NHTSA. Recall repairs are free at any Gem dealer.

Recalls

Complaints

Crashes / fires

0 / 1

Injuries / deaths

0 / 0

Recalls may cover only some 2003 Gem NEV vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2003 Gem NEV recalls

Recall 06V-222: Electrical System

Reported Jun 21, 2006 · 27,350 vehicles affected · GLOBAL ELECTRIC MOTORCARS, LLC

Problem: On certain 2 and 4 passenger, short and long bed low speed vehicles, the 12 volt output from the auxiliary card circuit board (A DC voltage to DC voltage converter) may become inoperative and result in loss of headlamp, tail lamp and turn signal lamp functions.

Risk: A loss of headlamps could impair a driver's visibility, increasing the risk of a crash. If there is a loss of tail lamp or turn signal lamp function, a following driver may not know when the brakes have been applied or that the vehicle in front is turning, a rear-end crash could occur without prior warning.

Fix: Dealers will replace the auxiliary cards, install a splash/spray protection, and adjust the dash seal free of charge. The recall began on september 11, 2006. Owners may contact global electric at 888-871-4367.

2003 Gem NEV problems reported by owners

Problem area	Reports
Suspension	1
Electrical System	1

Most reported parts

Suspension › Front — 1

Typical mileage at the time of the problem: 1,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2003 Gem NEV complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · at 1,000 miles · reported Jul 15, 2009

Fire inside dash of vehicle. Fire was caused by a defective module that already has a safety recall. The mfg. Will not replace parts/repair vehicle. They state vehicle had recall done already. Replacement parts are not available as the recall updates supercedes these parts with an upgrade kit (The recall).

Suspension · reported Apr 17, 2007

The contact owns a 2003 chrysler electric gem. While driving at 10 MPH the contact heard a loud clinking noise coming from the front of the vehicle. The faster the vehicle accelerated the louder the noise became . The contact called global electric motor company, and they suggested that the failure may be the front axle. The necessary parts for the repair were on back order. The current mileage was 7,346, and failure mileage was unknown. The consumer stated that the dealer set up appointment and came to repair the vehicle. Update 05/04/07

Other Gem NEV years

2007 2006 200420032002 2001 2000

Compare all Gem NEV years · All Gem models

Frequently asked questions

Does the 2003 Gem NEV have any recalls?

Yes — NHTSA lists 1 recall for the 2003 Gem NEV: 06V-222 (electrical system). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2003 Gem NEV?

Owners report suspension problems most often (1 reports), followed by electrical system (1). The typical mileage when problems were reported is about 1,000 miles.

Are Gem recall repairs free?

Yes. Safety recall repairs are free at authorized Gem dealers, whether you are the first owner or bought the car used.