2016 Ford F-53 recalls
Reported Sep 30, 2015 · 1,477 vehicles affected · Ford Motor Company
Problem: Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-53 and F-59 stripped chassis trucks manufactured June 1, 2015, to August 11, 2015. Due to an incorrect shift cable bracket and an improper shift cable adjustment, the affected vehicles can be shifted out of 'PARK' without applying the brakes.
Risk: If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.
Fix: Ford will notify owners, and dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S25.
2016 Ford F-53 problems reported by owners
| Problem area | Reports | |
|---|
| Power Train | 6 | |
| Service Brakes | 2 | |
| Electrical System | 2 | |
| Unknown or Other | 2 | |
| Structure | 2 | |
| Visibility/Wiper | 1 | |
| Engine | 1 | |
| Visibility | 1 | |
| Seat Belts | 1 | |
Most reported parts
- Structure › Body — 1
- Visibility › Windshield Wiper/Washer — 1
Typical mileage at the time of the problem: 2,800 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2016 Ford F-53 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Structure · reported Nov 7, 2025
The contact owns a 2016 Ford F-53. The contact stated that upon further inspection of the vehicle, the contact noticed that the chassis body had several fractured welds, and the brackets were missing. The vehicle was taken to a local independent mechanic, where it was diagnosed that the brackets holding the chassis body of the frame were fractured. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.
Seat Belts · at 24,000 miles · reported Mar 22, 2022
The contact owns a 2016 Fleetwood Flair RV built on a 2016 Ford F53 Chassis. The contact stated that the dealer had repaired the seat belt bolts upon purchasing the RV; however, while her husband was driving approximately 55-65 MPH in the mountains with her in the front passengerâs side seat, the front driver's side seat belt detached from the wall while it was buckled. The contact's husband pulled to the side of the road. Upon inspecting the front passenger's side seat belt, the contact's husband noticed that it was also loosened. The RV was taken to the dealer and was being repaired. The…
Service Brakes · at 2,800 miles · reported Apr 18, 2018
Purchased new in august, 2016. One month later we drove our new motorhome southwest into nm and az. At 2735 miles on the odometer in central nm we got two brake system warning lights while traveling west on I-40 at 65 MPH. We stopped to inspect system. Front brake rotors were extremely hot! Front master cylinder chamber spilled out extremely hot brake fluid! I adjusted it's level then checked rear chamber. It was about 2' below correct level. I filled to correct level. For several hours before this I noticed a very hard brake pedal with decreasing brake efficiency. We stopped in albuquerque…
Electrical System · reported May 31, 2017
Electrical transfer switch buzzes after one to two hours of plugging in. Louder after more hours. Hydraulic jack pump replaced twice in first year and needs repair or replace again after 13 months.
Structure · at 270 miles · reported Sep 14, 2016
Purchased new. Took home from dealer after customer inspection but batteries were dead preventing full operation of amenities. Six days after being home, we were going to take the motorhome on a trip. Kitchen slide was open since we brought it home. Try to retract kitchen slide and it jammed. Problem is the room slide is too big for the opening in the wall causing unit to bind (One motor works, other does not) overloading and burning out motors. Also, metal screws driven in to channel in wall going to slide motors penetrated red wire to front slide motor. Motorhome had 270 miles on it when…
Frequently asked questions
Does the 2016 Ford F-53 have any recalls?
Yes — NHTSA lists 1 recall for the 2016 Ford F-53: 15V-611 (power train). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2016 Ford F-53?
Owners report power train problems most often (6 reports), followed by service brakes (2). The typical mileage when problems were reported is about 2,800 miles.
Are Ford recall repairs free?
Yes. Safety recall repairs are free at authorized Ford dealers, whether you are the first owner or bought the car used.