2002 Ford Econoline recalls and problems

The 2002 Ford Econoline has 2 safety recalls and 23 owner complaints filed with NHTSA. Recall repairs are free at any Ford dealer.

Recalls

Complaints

Crashes / fires

0 / 3

Injuries / deaths

0 / 0

Recalls may cover only some 2002 Ford Econoline vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 Ford Econoline recalls

Recall 08V-051: Vehicle Speed Control

Reported Feb 4, 2008 · 225,000 vehicles affected · FORD MOTOR COMPANY

Problem: Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.

Risk: As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.

Fix: Dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.

Recall 03V-282: Fuel System, Gasoline

Reported Aug 5, 2003 · 64 vehicles affected · FORD MOTOR COMPANY

Problem: On certain cutaway chassis cab with the school bus option, two brackets and two outrigger members are missing in the area of the fuel tank.

Risk: The brackets and outrigger members are intended to enhance crash performance.

Fix: Ford will send technicians to the owner's location to inspect and add the brackets and outriggers as required. Owner notification began on september 3, 2003. Owners should contact ford at 1-800-392-3673.

2002 Ford Econoline problems reported by owners

Problem area	Reports
Engine and Engine Cooling	6
Vehicle Speed Control	5
Steering	2
Service Brakes, Hydraulic	2
Electrical System	2
Fuel/Propulsion System	2
Engine	2
Structure	1
Suspension	1
Fuel System, Gasoline	1
Tires	1

Most reported parts

Engine and Engine Cooling › Engine — 4
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 2
Engine and Engine Cooling › Engine › Gasoline — 1
Steering › Steering Wheel/Handle Bar — 1
Structure › Frame and Members — 1
Steering › Linkages › Tie Rod Assembly — 1
Suspension › Front › Springs › Coil Springs — 1
Fuel System, Gasoline › Storage — 1

Typical mileage at the time of the problem: 98,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 Ford Econoline complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine · at 150,000 miles · reported Oct 14, 2017

Left house for vacation, got 75 miles away at 60 MPH on the freeway, and engine started making a popping sound. Pulled off road and called a nearby mobile repair company. They sent out a mechanic, he diagnosed a blown out spark plug, and said this was common for the ford V-10. Made it to his shop, and that's where it sits. Estimates are over $4000 to repair.

Fuel/Propulsion System · at 76,000 miles · reported Oct 18, 2012

The contact owns a 2002 ford econoline e-150. The contact stated that while driving approximately 30 MPH, he heard a loud, abnormal noise from the vehicle. After stopping the vehicle for further inspection, the contact discovered that the rear end of the fuel tank had detached from the vehicle. In addition, one of the fuel tank straps had become completely corroded. The vehicle was driven cautiously and was later taken to the dealer. The dealer confirmed the failure of the fuel tank straps and installed a temporary strap for the fuel tank. The manufacturer was not contacted. The failure and…

Engine · at 98,000 miles · reported Jul 16, 2012

Took the van to the store. Upon returning from store started the van, there was a loud explosion as if a bomb went off. Everyone looked because it was so loud. Turned the van off and restarted it. It sounded like a drag car at the track, no exhaust system at all. Took cow off and looked inside, found the spark plug with the boot laying on top of the valve cover or intake, not sure there is no room and just enough to get two fingers in to retrieve it. I had noticed a little ticking earlier in the day like an exhaust leak, but did not find one. Had vehicle towed to repair shop, where it is now.…

Fuel/Propulsion System · at 96,517 miles · reported May 21, 2012

Fuel pump failed while driving vehicle at freeway speeds on 101 south on the waldo grade approaching the golden gate bridge. Vehicle lost power half way up the grade and slowed to 10 MPH. Limped vehicle to off ramp. I AM an ase certified master mechanic, I also hold my california smog license. I've worked as a mechanic for 30 years. Upon getting the vehicle home I diagnosed the concern I found the fuel tank full of metal that had flaked fromt he walls of the fuel tank. I found the fuel pickup in the tank plugged with filings, the fuel pump ruined, and the fuel filter full of metal and rust. I…

Service Brakes, Hydraulic · at 54,500 miles · reported Jan 11, 2010

The contact owns a 2006 ford econoline(Na). While driving and engaging the brake pedal, the warning light came. There was also noise under the hood of his vehicle. The contact stated that the anti lock brake system suddenly caught fire. He turned the vehicle off and waited for an hour to restart it; however, when he attempted to drive smoke and fire were coming from the brakes. He shut the engine off, extinguished the fire, and disconnected the ABS module unit under the hood. The contact was able to drive to the dealer who did not reconnect the ABS module. The contact is currently able to…

Other Ford Econoline years

2026 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2007 2006 2005 200320022001 2000

Compare all Ford Econoline years · All Ford models

Frequently asked questions

Does the 2002 Ford Econoline have any recalls?

Yes — NHTSA lists 2 recalls for the 2002 Ford Econoline: 08V-051 (vehicle speed control), 03V-282 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2002 Ford Econoline?

Owners report engine and engine cooling problems most often (6 reports), followed by vehicle speed control (5). The typical mileage when problems were reported is about 98,000 miles.

Are Ford recall repairs free?

Yes. Safety recall repairs are free at authorized Ford dealers, whether you are the first owner or bought the car used.