2006 Fleetwood Expedition recalls and problems
The 2006 Fleetwood Expedition has 4 safety recalls and 7 owner complaints filed with NHTSA. Recall repairs are free at any Fleetwood dealer.
Recalls may cover only some 2006 Fleetwood Expedition vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2006 Fleetwood Expedition recalls
Recall 09V-056: Electrical System
Problem: Fleetwood is recalling 3,782 my 2006-2009 providence, excursion, expedition, discovery and boulder diesel motor homes. The battery cable is routed too close to a sharp edge located on top of a shelf installed over the driveshaft.
Risk: This can cause abrasion to the battery cable insulation, leading to an electrical short and possibly a fire.
Fix: Dealers will re-route the cable away from the sharp edge location. This service will be performed for you free of charge. The recall began on may, 26 2009. Owners may contact fleetwood at 800-509-3418.
Recall 08V-320: Equipment
Problem: Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (Gas flame) is present.
Risk: If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
Fix: Fleetwood is working with dometic to repair these refrigerators (Please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216.
Recall 06V-055: Equipment
Problem: On certain motor homes equipped with kwikee brand electric entry step built with a control unit manufactured by american technologies, may develop an electrical short during cold weather, allowing for the potential of the plastic case to ignite.
Risk: This will make the step inoperable and possibly result in a risk of personal injury, vehicle or other property damage.
Fix: Dealers will inspect and, if necessary, replace all american technologies controls associated with the kwikee brand electric entry step free of charge. The recall began on march 17, 2006. Owners may contact fleetwood at 800-509-3418.
Recall 05V-333: Equipment
Problem: Certain diesel class a motor homes fail to comply with the requirements of part 567, "certification." the manufacturers' tow hitch receiver information label was printed with the incorrect weight carrying capacity value and the incorrect tongue weight value.
Risk: The weight label on the hitch receiver provides the maximum trailer weight rating and the maximum tongue weight rating. It is important that these ratings not be exceeded. Failure to comply could result in damage to the motor home frame, body, or hitch receiver and could cause unstable driving and handling characteristrics which may result in a vehicle crash.
Fix: Fleetwood will mail owners the correct tow hitch receiver weight information label. If owners do not feel comfortable installing the label, dealers will install the label for them. The recall began august 4, 2005. Owners may contact fleetwood at 800-509-3418.
2006 Fleetwood Expedition problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Visibility | 4 | |
| Visibility/Wiper | 2 | |
| Structure | 1 | |
| Electrical System | 1 |
Most reported parts
- Visibility › Rearview Mirrors/Devices › Exterior — 1
- Visibility › Glass, Side/Rear — 1
- Electrical System › Wiring › Interior/Under Dash — 1
Typical mileage at the time of the problem: 14,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Fleetwood Expedition complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Fleetwood Expedition years
Compare all Fleetwood Expedition years · All Fleetwood models
Frequently asked questions
Does the 2006 Fleetwood Expedition have any recalls?
Yes — NHTSA lists 4 recalls for the 2006 Fleetwood Expedition: 09V-056 (electrical system), 08V-320 (equipment), 06V-055 (equipment), 05V-333 (equipment). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2006 Fleetwood Expedition?
Owners report visibility problems most often (4 reports), followed by visibility/wiper (2). The typical mileage when problems were reported is about 14,000 miles.
Are Fleetwood recall repairs free?
Yes. Safety recall repairs are free at authorized Fleetwood dealers, whether you are the first owner or bought the car used.