2008 Fleetwood Discovery recalls and problems
The 2008 Fleetwood Discovery has 7 safety recalls and 3 owner complaints filed with NHTSA. Recall repairs are free at any Fleetwood dealer.
Recalls may cover only some 2008 Fleetwood Discovery vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2008 Fleetwood Discovery recalls
Recall 09V-175: Electrical System
Problem: Fleetwood is recalling 311 my 2008-2009 providence, excursion, expedition, discovery and bounder diesel motor home. The battery cable may become dislodged and come in contact with the driver shaft causing entanglement or abrasion to the battery cable.
Risk: This could lead to an electrical short which may result in a fire or un-commanded vehicle shutdown which may result in a loss of vehicle control.
Fix: Dealers will inspect and replace damage battery cables and secure the battery cable harness above the drive shaft free of charge. The recall is expected to begin during june 2009. Owners may contact fleetwood at 1-800-509-3418.
Recall 09V-056: Electrical System
Problem: Fleetwood is recalling 3,782 my 2006-2009 providence, excursion, expedition, discovery and boulder diesel motor homes. The battery cable is routed too close to a sharp edge located on top of a shelf installed over the driveshaft.
Risk: This can cause abrasion to the battery cable insulation, leading to an electrical short and possibly a fire.
Fix: Dealers will re-route the cable away from the sharp edge location. This service will be performed for you free of charge. The recall began on may, 26 2009. Owners may contact fleetwood at 800-509-3418.
Recall 08V-292: Equipment
Problem: Fleetwood is recalling 226 my 2008-2009 american allegiance, american eagle, american heritage, american tradition, bounder, bounder diesel, discovery, excursion, expedition, fiesta lx, pace arrow, providence, revolution le, southwind, class a motor homes, and icon, jamboree, jamboree gt, jamboree sport, pulse, tioga, and tioga ranger class c motor homes. These motor homes fail to comply with the requirements of the code of federal regulations, part 567, 'certification.' the occupant and cargo carrying capacity were calculated incorrectly allowing additional load carrying capacity.
Risk: Overloading may have an adverse affect on motor home handling, increasing the risk of a crash.
Fix: Fleetwood will mail a corrected federal certification label along with installation instructions to the affected motor home owners. Owners who do not feel comfortable installing this label can take their motor home to any fleetwood dealer and the dealer will install the label for them. The recall began on july 28, 2008. Owners may contact fleetwood at 1-800-509-3418.
Recall 08V-269: Suspension
Problem: Daimler trucks is recalling 2,506 my 2008 xc motor home chassis and thomas built hdx school and transit buses equipped with saf-holland adl series rear suspensions. In some instances the transverse beam was not properly welded which could result in a failure of the weld.
Risk: If the weld fails, vehicle stability while cornering could be affected resulting in loss of vehicle control, possibly resulting in a crash. In addition, the transverse beam could drop to the ground causing sparks that could cause a fire hazard.
Fix: Daimler trucks is working with saf-holland to have a visual inspection of the adl transverse beam performed. If a weld defect is identified, saf-holland will provide a service replacement kit that contains a new transverse beam, all necessary installation hardware, beam replacement, and instructions free of charge (Please see 08e031). The recall recall began on september 12, 2008 (Thomas built buses) and october 8, 2008. Owners may contact saf-holland at 1-231-773-3271 or daimler trucks at 1-800-547-0712.
Recall 08V-013: Electrical System
Problem: On certain motor homes equipped with a field effect transistor (Fet) board built by magnum energy, inc., the circuitry inside certain inverters can cause an inoperative condition resulting in overheating of the inverter.
Risk: Overheating of the inverter may result in a potential fire.
Fix: Dealers will inspect and replace the inverter free of charge. The recall began on january 19, 2008. Owners may contact fleetwood at 1-800-509-3418.
Recall 07V-365: Equipment
Problem: On certain 39r motor homes, the propane hose, under the galley slide-out room, can flex and make contact with other components during the slide-out room operation.
Risk: This may lead to abrasion or kinking of the propane hose which may result in a propane gas leak and the potential for an explosion and/or fire.
Fix: Fleetwood will replace the propane gas hose if it is kinked or damaged. If the hose is not kinked or damaged, fleetwood will install insulated loop clamps to secure the propane hose away from components. Fleetwood began calling customers on august 3, 2007. A customer notification mailing began on september 6, 2007. Owners may contact fleetwood at 1-800-322-8216.
Recall 07V-306: Steering
Problem: Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (Aac) front axles. During the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
Risk: Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
Fix: Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. The recall began on december 21, 2007. Owners can contact freightliner at 1-800-547-0712.
2008 Fleetwood Discovery problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Electrical System | 2 | |
| Visibility/Wiper | 1 |
Typical mileage at the time of the problem: 14,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2008 Fleetwood Discovery complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Fleetwood Discovery years
Compare all Fleetwood Discovery years · All Fleetwood models
Frequently asked questions
Does the 2008 Fleetwood Discovery have any recalls?
Yes — NHTSA lists 7 recalls for the 2008 Fleetwood Discovery: 09V-175 (electrical system), 09V-056 (electrical system), 08V-292 (equipment), 08V-269 (suspension), 08V-013 (electrical system) and more. Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2008 Fleetwood Discovery?
Owners report electrical system problems most often (2 reports), followed by visibility/wiper (1). The typical mileage when problems were reported is about 14,000 miles.
Are Fleetwood recall repairs free?
Yes. Safety recall repairs are free at authorized Fleetwood dealers, whether you are the first owner or bought the car used.